Abstract:Heterogeneous integration enables high-density integration to improve system functionality, but meanwhile brings reliability concerns due to the intensification of temperature and thermal stress. However, research on thermal stress effects in nanoscale transistors within heterogeneous integrated circuit is still very limited up to now. Multiphysics computation for the heterogeneous integration of nanoscale p-FinFET with GaN high electron mobility transistor (HEMT) on silicon substrate is performed. Firstly, self-heating of GaN HEMT induced thermal stress is simulated. Then, thermal stress effects induced by the GaN HEMT on quantum transport in the FinFET at different locations are compared and analyzed, including the hole effective mass, hole average velocity, on/off-state current, and on-off ratio. Moreover, the impacts of crystal orientation configurations are further discussed. Simulation results show that the impact of thermal stress on FinFET is highly dependent on the Si crystal orientation and its location relative to GaN HEMT. Taking the FinFET with (001)/[110] confinement/transport orientation, which is at a distance of R FET and an angle of φ from the GaN HEMT as an example, thermal stress induces the significant reductions in I on and I off of FinFET at φ = π/2 and φ = 3π/2, and the increases of I on and I off in FinFET at φ = 0 and φ = π, but has small impact on FinFETs located diagonally to the GaN HEMT.

Transmission Line Pulse Induced Breakdown of FinFETs

Physical Study of Low-frequency TDDB Lifetime Deterioration in Advanced FinFETs

Electrothermal-Stress Interactions of LDMOS FET Induced by DCI RF-Pulses

Electro-Thermal-Stress analysis of a LDMOS FET Breakdown under High Power Microwave pulses

Interconnection Reliability on FinFET Devices

Breakdown Voltage of Ultrathin Dielectric Film Subject to Electrostatic Discharge Stress

Catching the Missing EM Consequence in Soft Breakdown Reliability in Advanced FinFETs: Impacts of Self-heating, On-State TDDB, and Layout Dependence.

Off-state Avalanche Breakdown Induced Degradation in 20 V NLDMOS Devices

An Electro-Thermal Analysis of Lateral Double-diffused MOSFET(LDMOS) Using FEM

Effects of Non-Fatal Electrostatic Discharge on the Threshold Voltage Degradation in Nano CMOS Devices

Time-Dependent Dielectric Breakdown on Subnanometer EOT nMOS FinFETs

Breakdown-limited endurance in HZO FeFETs: mechanism and improvement under bipolar stress

Deep insights into dielectric breakdown in tunnel FETs with awareness of reliability and performance co-optimization

GHz AC to DC TDDB Modeling with Defect Accumulation Efficiency Model

Total-Ionizing-Dose Effects and Low-Frequency Noise in 30-Nm Gate-Length Bulk and SOI FinFETs with SiO2/HfO2Gate Dielectrics

Multiphysics Simulation Study of Thermal Stress Effects in Nanoscale FinFETs Heterogeneously Integrated with GaN High-Power Device on Silicon Substrate

On the ESD Protection and Non-Fatal ESD Strike on Nano CMOS Devices

A comprehensive analysis of breakdown mechanisms in 4H-SiC MOSFET and JFET

Suppression of Stress-Induced Defects in FinFET by Implantation and STI Co-Optimization

Localized Breakdown in Dielectrics and Macroscopic Charge Transport Through the Whole Gate Stack: A Comparative Study

Investigation of the Off-State Degradation in Advanced FinFET Technology—Part I: Experiments and Analysis