Abstract:The phosphorus doped n-type hydrogenated microcrystalline silicon (n-μc-Si:H) thin films are prepared, at the two low substrate temperatures of room temperature and 200°C, through a low-frequency inductively coupled plasma assisted chemical vapor deposition. The effect of the substrate temperature on the structural properties of the thin films, such as the X-ray Diffraction (XRD) patterns and the Raman spectra, is studied. The XRD measurements show that the diffraction orientations of the thin films present an obvious change when the radio frequency power is increased from 1300W to 2300W. The Raman spectra of the thin films deposited at room temperature unambiguously present a phase transition from the amorphous structure to microcrystalline structure whereas no structural phase transition is observed for the thin films deposited at 200°C. The effect of the substrate temperature on the crystalline volume fraction of the thin films presents a large difference for the radio frequency power in the range of 1300W–1700W, while the difference becomes small when the power is increased from 1700W to 2300W. The deposition rate and the radio frequency power-sheet resistance curve of the thin films deposited at room temperature are obviously different from those of the thin films prepared at 200°C. It is attributed to the joint effect of the radio frequency power and substrate temperature on the doping concentration. The electron energy distribution function of the species in the chamber is mainly distributed in a low energy range.

Analysis of Heating Effect on the Process of High Deposition Rate Microcrystalline Silicon

A New Method Used to Control the Structure of High Rate Microcrystalline Silicon Thin Films

The Effects of Extended Heat Treatment on Ni Induced Lateral Crystallization of Amorphous Silicon Thin Films

Effects of Total Gas Flow Rates on the High Rate Growth Microcrystalline Silicon Thin Films

High Rate Deposition of Microcrystalline Silicon Films Using Jet-Type Inductively Coupled Plasma Chemical Vapor Deposition

High Rate Deposition of Stable Hydrogenated Amorphous Silicon in Transition from Amorphous to Microcrystalline Silicon

Influence of the Total Gas Flow Rate on High Rate Growth Microcrystalline Silicon Films and Solar Cells

High-Rate Deposition of Microcrystalline Silicon Thin Film by Multi-Step Method

Influence of Total Gas Flow Rate on Microcrystalline Silicon Films Prepared by VHF-PECVD

Effects of Drift Due to Chamber's Long-time Usage on Microcrystalline Silicon Properties

Non-equilibrium,Atmospheric-pressure Plasma Jet for Depositing Silicon Oxide Films

Microcrystalline Silicon Materials and Solar Cells with High Deposition Rate

Highly Doped P-Type Microcrystalline Silicon Thin Films Fabricated by A Low-Frequency Inductively Coupled Plasma at A Low Temperature

Fabrication of 1nm/s High Deposition Microcrystalline Silicon and Its Application in Solar Cells

Influence of Substrate on the Growth of Microcrystalline Silicon Thin Films Deposited by Plasma Enhanced Chemical Vapor Deposition

THE OES IN DEPOSITING MICROCRYSTALLINE SILICON MATERIAL BY RF-PECVD

Effect of Substrate Temperature and Pressure on Properties of Micro Crystalline Silicon Films

Study on the Growth Mechanism and Microstructure of High Rate Growth Μc-Si:H Thin Films

Parametric Study and Residual Gas Analysis of Large-Area Silicon-Nitride Thin-Film Deposition by Plasma-Enhanced Chemical Vapor Deposition

Low-temperature preparation of phosphorus doped μc -Si:H thin films by low-frequency inductively coupled plasma assisted chemical vapor deposition

Effect of High Deposition Rate on Chemical Bonds and Properties of SiN Film