Abstract:The phosphorus doped n-type hydrogenated microcrystalline silicon (n-μc-Si:H) thin films are prepared, at the two low substrate temperatures of room temperature and 200°C, through a low-frequency inductively coupled plasma assisted chemical vapor deposition. The effect of the substrate temperature on the structural properties of the thin films, such as the X-ray Diffraction (XRD) patterns and the Raman spectra, is studied. The XRD measurements show that the diffraction orientations of the thin films present an obvious change when the radio frequency power is increased from 1300W to 2300W. The Raman spectra of the thin films deposited at room temperature unambiguously present a phase transition from the amorphous structure to microcrystalline structure whereas no structural phase transition is observed for the thin films deposited at 200°C. The effect of the substrate temperature on the crystalline volume fraction of the thin films presents a large difference for the radio frequency power in the range of 1300W–1700W, while the difference becomes small when the power is increased from 1700W to 2300W. The deposition rate and the radio frequency power-sheet resistance curve of the thin films deposited at room temperature are obviously different from those of the thin films prepared at 200°C. It is attributed to the joint effect of the radio frequency power and substrate temperature on the doping concentration. The electron energy distribution function of the species in the chamber is mainly distributed in a low energy range.

Control of crystalline volume fraction of μC-Si thin film using 40.68 MHz PECVD system for solar cell application

Single-chamber Deposition of Intrinsic Microcrystalline Silicon Thin Film and Its Application in Solar Cells

Microcrystalline Silicon Thin Film Solar Cells with Microcrystalline Silicon Carbide Window Layers and Silicon Absorber Layers Both Prepared by Hot‐Wire CVD

Microcrystalline silicon carbide window layers in thin film silicon solar cells

Microcrystalline silicon carbide thin films grown by HWCVD at different filament temperatures and their application in n-i-p microcrystalline silicon solar cells

The Study of Microcrystalline Silicon Thin Films Prepared by PECVD

Microcrystalline SiGe Prepared by VHF-PECVD for Thin Film Solar Cells

Advanced PECVD Processes for SiNW Based Solar Cells and Thin Film Transistors

Microcrystalline Silicon‐carbon Alloys As Anti‐reflection Window Layers in High Efficiency Thin Film Silicon Solar Cells

Study on the Growth Mechanism and Microstructure of High Rate Growth Μc-Si:H Thin Films

Influence of the Total Gas Flow Rate on High Rate Growth Microcrystalline Silicon Films and Solar Cells

Influence of Substrate on the Growth of Microcrystalline Silicon Thin Films Deposited by Plasma Enhanced Chemical Vapor Deposition

Key Issues for High-Efficiency Silicon Thin Film Solar Cells Prepared by RF-PECVD under High-Pressure-depletion Conditions

STUDY ON MICROCRYSTALLINE SILICON THIN FILM SOLAR CELLS ON FLEXIBLE SUBSTRATE

A New Method Used to Control the Structure of High Rate Microcrystalline Silicon Thin Films

A PRELIMINARY STUDY ON MICROCRYSTALLINE SILICON MATERIALS AND SOLAR CELLS FABRICATED BY VHF-PECVD

Modulation Effect of Plasma Power on Crystalline Volume Fraction of Silicon Films in the Phase Transition from A-Si:H to /spl Mu/c-Si:H

Doped Microcrystalline Silicon Layers for Solar Cells by 13.56 Mhz Plasma-Enhanced Chemical Vapour Deposition

Low-temperature preparation of phosphorus doped μc -Si:H thin films by low-frequency inductively coupled plasma assisted chemical vapor deposition

Microcrystalline Silicon Materials and Solar Cells with High Deposition Rate

Preparation and Photoluminescence of Nanocrystalline Si-Rich Silicon Oxide Films by Pecvd