Abstract:The phosphorus doped n-type hydrogenated microcrystalline silicon (n-μc-Si:H) thin films are prepared, at the two low substrate temperatures of room temperature and 200°C, through a low-frequency inductively coupled plasma assisted chemical vapor deposition. The effect of the substrate temperature on the structural properties of the thin films, such as the X-ray Diffraction (XRD) patterns and the Raman spectra, is studied. The XRD measurements show that the diffraction orientations of the thin films present an obvious change when the radio frequency power is increased from 1300W to 2300W. The Raman spectra of the thin films deposited at room temperature unambiguously present a phase transition from the amorphous structure to microcrystalline structure whereas no structural phase transition is observed for the thin films deposited at 200°C. The effect of the substrate temperature on the crystalline volume fraction of the thin films presents a large difference for the radio frequency power in the range of 1300W–1700W, while the difference becomes small when the power is increased from 1700W to 2300W. The deposition rate and the radio frequency power-sheet resistance curve of the thin films deposited at room temperature are obviously different from those of the thin films prepared at 200°C. It is attributed to the joint effect of the radio frequency power and substrate temperature on the doping concentration. The electron energy distribution function of the species in the chamber is mainly distributed in a low energy range.

Molecular-Dynamics Simulation of Low-Temperature Growth of Silicon Films by Cluster Deposition

Simulation study on Si and Ge film growth by cluster deposition

Deposition of an Energetic Al Cluster on Si(111) Substrate: A Molecular Dynamics Simulation

Molecular-dynamics Simulation of Germanium Film Growth by Cluster Deposition

Molecular-dynamics Simulation of Ge Film Growth by Cluster Deposition

Novel Sandwich Structure for Aluminum Induced Crystallization of Amorphous Silicon Thin Films at Low Temperature

Microstructure and Conductivity of Large Area Nanocrystalline Silicon Films Grown by Specially Designed Thermal-Assisted Chemical Vapor Deposition

Growth of Poly-Crystalline Si Films on Flexible Substrate by Hot Wire Chemical Vapor Deposition

Silicon nano-wires grown at low temperature

Effect of Substrate Temperature on the Growth and Properties of Boron-Doped Micro Crystalline Silicon Films

Investigation on the initial growth of nanocrystalline silicon prepared from hydrogen-diluted SiCl<sub>4</sub> at low temperatures

The Effect of Temperature on Silicon Nucleation from Melt in Seed-assisted Growth — a Molecular Dynamics Study

Low-temperature preparation of phosphorus doped μc -Si:H thin films by low-frequency inductively coupled plasma assisted chemical vapor deposition

In situ observation and numerical analysis of temperature gradient effects on growth velocity during directional solidification of silicon

Influence of Substrate Temperature on the Growth of Μc-Sige Thin Film

Temperature-dependent Vibrational Spectra and Melting Behavior of Small Silicon Clusters Based Onab Initiomolecular Dynamics Simulations

Study of Ge Epitaxial Growth on Si Substrates by Cluster Beam Deposition

Precipitation and Crystallization of Nanometer Si Clusters in Annealed Si-Rich Sio2 Films

Optical and surface properties of 3C–SiC thin epitaxial films grown at different temperatures on 4H–SiC substrates

Molecular Dynamics Simulations of Pulsed Laser Crystallization of Amorphous Silicon Ultrathin Films

Low-Temperature Synthesis of C-60 Thin Films by Ionized Cluster Beam Deposition Technique