Abstract:Reactive ion etching (RIE) using fluorinated gases, such as admixtures of CF4 with O2, has been conducted on sputter deposited films of SiC. For comparison purposes, the same experiments with SiO2 films and Si wafers have been conducted. The influence of rf power, pressure, and O2 concentration on etch rate in CF4+O2, SF6+He, and Ar gases has been investigated. RIE mechanisms were studied using in situ monitoring of excited fluorine emission intensity and dc self-bias at the lower electrode. Typical etch rates of Si, SiO2, and SiC are 1220, 600, and 375 Å/min in CF4+4% O2; 8850, 500, and 560 Å/min in SF6+50% He; and 340, 280, and 270 Å/min in Ar, respectively, at P=200 W, p=20 mTorr, and 300 K. Under these conditions the dc self-bias levels are −396 V for CF4+4% O2, −350 V for SF6+50% He, and −414 V for Ar. In both CF4+4% O2 and SF6+50% He, the etch rates of Si, SiO2, and SiC all increase monotonically with the rf power. However, with increasing pressure the Si etch rate increases while the etch rates of SiO2 and SiC decrease. Since the dc self-bias varies proportionally with power and inversely with pressure, it is clear that the etching of Si is chemical reaction rate controlled. On the other hand, the etch rate of SiC depends on the ion bombardment energy and is thus dominantly controlled by a physical reaction. The SiC etch rate exhibits a weak dependence on O2 concentration in CF4+O2 mixtures. The dc self-bias is not affected by increasing O2 concentration, but the SiC etch rate is slightly enhanced. This suggests that a certain etching inhibitor layer exists on the surface of SiC, which can weakly react with the O2 plasma. Auger electron spectroscopy data indicates that this layer consists of carbon atoms.

Synchrotron-Radiation-Induced Deposition of Etch-Protecting Film on Si in Cf4 Plasma

Deposition of Dense SiO2 Thin Films for Electrical Insulation Applications by Microwave ECR Plasma Source Enhanced RF Reactive Magnetron Sputtering

Synchrotron-Radiation-Excited Etching Of Silicon Wafer Enhanced By Disk-Shaped Cf4 Plasma

In-Flight Dry Etching of Plasma-Synthesized Silicon Nanocrystals

Isotropic Etch for SiO2 Microcantilever Release with ICP System

Reactive ion etching of plasma enhanced chemical vapor deposition amorphous silicon and silicon nitride: Feeding gas effects

Reactive ion etching of SiC thin films using fluorinated gases

The Influence of Radio Frequency Power on the Characteristics of Carbon-Rich Hydrogenated Amorphous Silicon Carbide Films

Silicon Wafer Etching by Transmitted Electron‐Beam‐Enhanced Plasma

Inductively Coupled Plasma etching of amorphous silicon nanostructures over nanotopography using C4F8/SF6 chemistry

Growth of Si-C-H film by RF plasma enhanced chemical vapor deposition

Dry Etching of Silicon Materials in SF 6 Based Plasmas: Roles of and Gas Additives

Etching Mechanisms of CF3Etching Fluorinated Si: Molecular Dynamics Simulation

Non-equilibrium,Atmospheric-pressure Plasma Jet for Depositing Silicon Oxide Films

Preparation and Photoluminescence of Nanocrystalline Si-Rich Silicon Oxide Films by Pecvd

Effects of Ethylene doping on Deposition Rate and Surface Profile of Silicon Films

Simulation of SiO<sub>2</sub> etching in an inductively coupled CF<sub>4</sub> plasma

Fluorine‐containing species on the hydrofluoric acid etched silicon single‐crystal surface

Simulation of SiO2 etching in an inductively coupled CF4 plasma

Investigation of SiO2 Etch Characteristics by C6F6/Ar/O2 Plasmas Generated Using Inductively Coupled Plasma and Capacitively Coupled Plasma

Study on optical emission spectrum of RF plasma during amorphous silicon based film etching