Abstract:Surface passivation of n-type Crystalline Silicon wafer using thin dielectric films is an important and major factor in improving photovoltaic performance of HIT solar cells. In this study, Numerical simulation was carried out by using AFORS-HET simulation software in which energy band diagram with and without surface passivation (a-Si:H(i)) was investigated and the highest conduction band offset obtained on n type c-Si wafer is 0.85 eV which is comparatively higher than p-type c-Si wafer which was reported between 0.1 and 0.15 eV. Performance of HIT solar cell with passivation layer is simulated and obtained efficiency of 12.9% by incorporating actual conditions to compare with experimentally obtained data. It has been understood that applying an effective dielectric passivation of silicon surface resulted with high open circuit voltage (Voc) and low surface recombination lead to an increase of cell efficiency by 1.1% (from 11.8 to 12.9%). Also, the simulated results shows that to obtain good conversion efficiency Defect density of interface (Dit) should be lower than 1x1011 cm−2eV−1.Validation of the simulation results is done by conducting PECVD experiments for optimizing the amorphous silicon passivation to a layer thickness down to 15 nm. HIT Solar cells have been developed, using the optimum layer of passivation, and their performance have been studied. An improvement in the minority charge carrier lifetime of ~53 µs (from 215 to 268 μs) and on the other hand reduction in the surface recombination velocity of ~ 12.9 cm/s (from 65.11 cm/s down to 52.23 cm/s) has been achieved through passivation which effectively increased the open circuit voltage (Voc) from 0.690 to 0.705 V. In this preliminary study, a conversion efficiency of 11.3% of heterojunction with intrinsic thin layer (HIT) solar cell on 10 mm × 10 mm n-c-Si wafer has been obtained.

Optimization and Neural Network-Based Modelling of Surface Passivation Effectiveness by Hydrogenated Amorphous Silicon for Solar Cell Applications

Surface Passivation Studies of n-type Crystalline Silicon for HIT Solar Cells

Intrinsic layer modification in silicon heterojunctions: Balancing transport and surface passivation

Study of the correlation between hydrogenated amorphous silicon microstructure and crystalline silicon surface passivation in heterojunction solar cells

Improved Amorphous/crystalline Silicon Interface Passivation for Silicon Heterojunction Solar Cells by Hot-Wire Atomic Hydrogen During Doped A-Si:H Deposition

Investigation of dual intrinsic a-Si:H films for crystalline silicon surface passivation by spectroscopic ellipsometry: application in silicon heterojunction solar cells

Amorphous/Crystalline Silicon Interface Stability: Correlation between Infrared Spectroscopy and Electronic Passivation Properties

Demonstration of Excellent Crystalline Silicon Surface Passivation (S < 1.27 cm/s) by High‐Rate DC‐Sputtered Hydrogenated Amorphous Silicon

Light-activated surface passivation for more efficient silicon heterojunction solar cells: Origin, physics and stability

Numerical Simulation Study for Analysis of Hydrogenated Amorphous Silicon/Crystalline Silicon Heterostructure by Reactive Molecular Dynamics Method

Real-time monitoring of surface passivation of crystalline silicon during growth of amorphous and epitaxial silicon layer

Importance of Nanocrystallites in A-Si:H Passivation Layer in Improving the Performance of Silicon Heterojunction Solar Cells

Amorphous silicon carbide passivating layers for crystalline-silicon-based heterojunction solar cells

High Passivation Performance of Cat-CVD i-a-Si:H Derived from Bayesian Optimization with Practical Constraints

Enhancement of Electrical Properties of Nanostructured Polysilicon Layers Through Hydrogen Passivation

Dry Passivation Process for Silicon Heterojunction Solar Cells Using Hydrogen Plasma Treatment Followed by In Situ a-Si:H Deposition

Numerical Design of Ultrathin Hydrogenated Amorphous Silicon-Based Solar Cell

Review—Process Research on Intrinsic Passivation Layer for Heterojunction Solar Cells

Impact of PECVD SiON stoichiometry and post-annealing on the silicon surface passivation

Effective Passivation of Black Silicon Surfaces via Plasma‐Enhanced Chemical Vapor Deposition Grown Conformal Hydrogenated Amorphous Silicon Layer

The microstructure of underdense hydrogenated amorphous silicon and its application to silicon heterojunction solar cells