Abstract:Surface passivation of n-type Crystalline Silicon wafer using thin dielectric films is an important and major factor in improving photovoltaic performance of HIT solar cells. In this study, Numerical simulation was carried out by using AFORS-HET simulation software in which energy band diagram with and without surface passivation (a-Si:H(i)) was investigated and the highest conduction band offset obtained on n type c-Si wafer is 0.85 eV which is comparatively higher than p-type c-Si wafer which was reported between 0.1 and 0.15 eV. Performance of HIT solar cell with passivation layer is simulated and obtained efficiency of 12.9% by incorporating actual conditions to compare with experimentally obtained data. It has been understood that applying an effective dielectric passivation of silicon surface resulted with high open circuit voltage (Voc) and low surface recombination lead to an increase of cell efficiency by 1.1% (from 11.8 to 12.9%). Also, the simulated results shows that to obtain good conversion efficiency Defect density of interface (Dit) should be lower than 1x1011 cm−2eV−1.Validation of the simulation results is done by conducting PECVD experiments for optimizing the amorphous silicon passivation to a layer thickness down to 15 nm. HIT Solar cells have been developed, using the optimum layer of passivation, and their performance have been studied. An improvement in the minority charge carrier lifetime of ~53 µs (from 215 to 268 μs) and on the other hand reduction in the surface recombination velocity of ~ 12.9 cm/s (from 65.11 cm/s down to 52.23 cm/s) has been achieved through passivation which effectively increased the open circuit voltage (Voc) from 0.690 to 0.705 V. In this preliminary study, a conversion efficiency of 11.3% of heterojunction with intrinsic thin layer (HIT) solar cell on 10 mm × 10 mm n-c-Si wafer has been obtained.

Light-activated surface passivation for more efficient silicon heterojunction solar cells: Origin, physics and stability

Amorphous/Crystalline Silicon Interface Stability: Correlation between Infrared Spectroscopy and Electronic Passivation Properties

Long-term stability study of the passivation quality of polysilicon-based passivation layers for silicon solar cells

Surface Passivation Studies of n-type Crystalline Silicon for HIT Solar Cells

Silicon Homo-Heterojunction Solar Cells: A Promising Candidate to Realize High Performance More Stably

Influence of Light Soaking on Silicon Heterojunction Solar Cells With Various Architectures

Balance of efficiency and stability of silicon heterojunction solar cells

Dry Passivation Process for Silicon Heterojunction Solar Cells Using Hydrogen Plasma Treatment Followed by In Situ a-Si:H Deposition

Impact of Surface Treatments on the Passivation Effect for N-Type Crystalline Silicon in Heterojunction Solar Cells

Interdigitated back contact silicon heterojunction solar cell and the effect of front surface passivation

Influence of intrinsic amorphous silicon passivation layer on the dark-state stability of SHJ cells

Improved Amorphous/crystalline Silicon Interface Passivation for Silicon Heterojunction Solar Cells by Hot-Wire Atomic Hydrogen During Doped A-Si:H Deposition

Insights into the Heat‐Assisted Intensive Light‐Soaking Effect on Silicon Heterojunction Solar Cells

Investigation of dual intrinsic a-Si:H films for crystalline silicon surface passivation by spectroscopic ellipsometry: application in silicon heterojunction solar cells

Factors Affecting the Performance of HJT Silicon Solar Cells in the Intrinsic and Emitter Layers: A Review

Study of the correlation between hydrogenated amorphous silicon microstructure and crystalline silicon surface passivation in heterojunction solar cells

Significant Improvement of Passivation Performance by Two-Step Preparation of Amorphous Silicon Passivation Layers in Silicon Heterojunction Solar Cells*

Importance of Nanocrystallites in A-Si:H Passivation Layer in Improving the Performance of Silicon Heterojunction Solar Cells

Damp-Heat-Stable, High-Efficiency, Industrial-Size Silicon Heterojunction Solar Cells

Hydrogen-induced degradation dynamics in silicon heterojunction solar cells via machine learning

The Development of Carbon/Silicon Heterojunction Solar Cells through Interface Passivation