Abstract:Silicon heterojunction (SHJ) solar cell that combines traditional pure H2 plasma treatments has been frequently reported in the literature. However, this method requires an individual gas blending step between a-Si:H film deposition and post H2 plasma treatment to stabilize the gas environment in the PECVD chamber. Here, we report the introduction of residual SiH4 molecules in H2 plasma to treat SHJ solar cell devices. In contrast to the traditional H2 plasma treatments, it requires no time interval between the a-Si:H film deposition and H2 plasma treatment, i.e., we merely closed the SiH4 inlet after the a-Si:H deposition. In the meantime, all other PECVD parameters were kept unchanged. Taking advantage of the decreasing SiH4 density during the H2 plasma process, a dense silicon layer was grown onto the top layer of the as-deposited a-Si:H film, which inhibited free H atoms effusing out of the low-mass-density a-Si:H network. The better a-Si:H/c-Si interface passivation results in improvements to both the short-circuit current density (Jsc) and open-circuit voltage (Voc) of the SHJ solar cell in comparison to the counterpart cell treated by the traditional pure H2 plasma. For instance, when the n+ a-Si:H window layer is as thin as ~ 1.8nm, the power-conversion efficiency skyrockets from 2.35% treated by the traditional pure H2 plasma to 16.09% treated by the H2 plasma containing residual SiH4 molecules. For a thicker n+ a-Si:H window layer of ~ 4.3nm, the efficiency is also enhanced from 20.66% to 22.74%. This finding paves the way for a more efficient H2 plasma treatment in pursuit of an outstanding SHJ solar cell.

Low-temperature deposition of µc-Si : H thin films by a low-frequency inductively coupled plasma for photovoltaic applications

Hydrogen-plasma-induced Rapid, Low-Temperature Crystallization of Μm-Thick A-Si:H Films

Deposition of Very-Low-Hydrogen-Containing Silicon at a Low Temperature Using Very-High-Frequency (162 MHz) SiH4 Plasma

High-Density Plasma-Enhanced Chemical Vapor Deposition Of Si-Based Materials For Solar Cell Applications

Control of crystalline volume fraction of μC-Si thin film using 40.68 MHz PECVD system for solar cell application

Low-temperature preparation of phosphorus doped μc -Si:H thin films by low-frequency inductively coupled plasma assisted chemical vapor deposition

Low Temperature and High Deposition Rate Fabricating A-Si:H Thin Films and Solar Cells

Amorphous/Crystalline Silicon Heterojunction Solar Cells Via Remote Inductively Coupled Plasma Processing

High Rate Deposition of Stable Hydrogenated Amorphous Silicon in Transition from Amorphous to Microcrystalline Silicon

Deposition and Characterization of High-Efficiency Silicon Thin-Film Solar Cells by HF-PECVD and OES Technology

Low Temperature SiNx:H Films Deposited by Inductively Coupled Plasma for Solar Cell Applications

Effect of Silane/hydrogen Ratio on Microcrystalline Silicon Thin Films by Remote Inductively Coupled Plasma

Microcrystalline silicon carbide window layers in thin film silicon solar cells

Microcrystalline Silicon‐carbon Alloys As Anti‐reflection Window Layers in High Efficiency Thin Film Silicon Solar Cells

Investigation on the initial growth of nanocrystalline silicon prepared from hydrogen-diluted SiCl<sub>4</sub> at low temperatures

Microcrystalline silicon carbide thin films grown by HWCVD at different filament temperatures and their application in n-i-p microcrystalline silicon solar cells

Development of Highly Stable Hydrogenated Amorphous Silicon Films for Application in Solar Cells

The Optoelectronic Properties of Silicon Films Deposited by Inductively Coupled Plasma CVD

Controllable A-Si:H/c-si Interface Passivation by Residual SiH4 Molecules in H-2 Plasma

Influence of Ultrathin Amorphous Silicon Layers on the Nucleation of Microcrystalline Silicon Films under Hydrogen Plasma Treatment

Transport properties of µc-Si:H films prepared by very high hydrogen-diluted silane plasma