Abstract:A new process to crystallize amorphous silicon without melting and the generation of excessive heating of nearby components is presented. We propose the addition of a molybdenum layer to improve the quality of the laser-induced crystallization over that achieved by direct irradiation of silicon alone. The advantages are that it allows the control of crystallite size by varying the applied fluence of a near-infrared femtosecond laser. It offers two fluence regimes for nanocrystallization and polycrystallization with small and large crystallite sizes, respectively. The high repetition rate of the compact femtosecond laser source enables high-quality crystallization over large areas. In this proposed method, a multilayer structure is irradiated with a single femtosecond laser pulse. The multilayer structure includes a substrate, a target amorphous Si layer coated with an additional molybdenum thin film. The Si layer is crystallized by irradiating the Mo layer at different fluence regimes. The transfer of energy from the irradiated Mo layer to the Si film causes the crystallization of amorphous Si at low temperatures (∼700 K). Numerical simulations were carried out to estimate the electron and lattice temperatures for different fluence regimes using a two-temperature model. The roles of direct phonon transport and inelastic electron scattering at the Mo-Si interface were considered in the transfer of energy from the Mo to the Si film. The simulations confirm the experimental evidence that amorphous Si was crystallized in an all-solid-state process at temperatures lower than the melting point of Si, which is consistent with the results from transmission electron microscopy (TEM) and Raman. The formation of crystallized Si with controlled crystallite size after laser treatment can lead to longer mean free paths for carriers and increased electrical conductivity.

Hydrogen-plasma-induced Rapid, Low-Temperature Crystallization of Μm-Thick A-Si:H Films

Rapid And Controllable A-Si:H-To-Nc-Si:H Transition Induced By A High-Density Plasma Route

Deposition of Very-Low-Hydrogen-Containing Silicon at a Low Temperature Using Very-High-Frequency (162 MHz) SiH4 Plasma

Nickel Induced Crystallization of Amorphous Silicon Thin Films

Low-temperature deposition of µc-Si : H thin films by a low-frequency inductively coupled plasma for photovoltaic applications

Rapid crystallization of amorphous silicon films utilizing Ar-H2 mesoplasma annealing

High Rate Deposition of Stable Hydrogenated Amorphous Silicon in Transition from Amorphous to Microcrystalline Silicon

Microwave-crystallization of Amorphous Silicon Film Using Carbon-Overcoat As Susceptor

Novel Sandwich Structure for Aluminum Induced Crystallization of Amorphous Silicon Thin Films at Low Temperature

Crystallization of Hydrogenated Amorphous Silicon Thin Films Using Combined Continuous Wave Laser and Thermal Annealing

Room Temperature Growth of Hydrogenated Amorphous Silicon Films by Dielectric Barrier Discharge Enhanced Cvd

High-Pressure Water-Vapor Annealing for Enhancement of A-Si:H Film Passivation of Silicon Surface

Deposition of a-Si:H thin films embedded with nano-crystalline through dilution of argon

Influence of Precursor A-Si:H Dehydrogenation on the Aluminum Induced Crystallization Process

Microwave Irradiation Induced Structural Evolution of A-Si:H Thin Film Before Crystallization

Behavior of hydrogen during laser crystallization and RTA of a-Si: H SOI

Nanocrystallization of a-Si:H thin films deposited by PECVD under low argon dilution

Ar+ laser crystallization of a-Si:H film for active layer of TFT

Confined high-pressure chemical deposition of hydrogenated amorphous silicon

Femtosecond Laser-Induced Crystallization of Amorphous Silicon Thin Films under a Thin Molybdenum Layer

Influence of Ultrathin Amorphous Silicon Layers on the Nucleation of Microcrystalline Silicon Films under Hydrogen Plasma Treatment