Abstract:Al2O3, as one of the gate dielectric materials for thin film transistors (TFTs), has been extensively investigated because of its large bandgap, high breakdown field, and good thermal stability. However, the further development of Al2O3 thin films is limited by the presence of defects such as oxygen vacancies, self-interstitial atoms, or impurity elements. To overcome this obstacle, we have developed a novel method for fabricating Al2O3 thin films by using the atomic layer deposition (ALD) technique. This method replaces the conventional Trimethylaluminium (TMA)/H2O cycles with TMA/TMA/H2O/H2O cycles (referred to as ‘double cycles’), to deposit the Al2O3. The 5-nm ultrathin Al2O3 film showed a high areal capacitance of 660 nF/cm2 at 20 Hz, and a relatively low current density of 10−8 A/cm2 at 1 MV/cm. InGaZnO (IGZO) TFTs with ultrathin Al2O3 gate dielectric grown by double cycles exhibited outstanding performances, such as a near theoretical limit subthreshold swing (SS) of 70 mV/decade, a higher on/off current ratio $(I_{\mathrm{ on}} / I_{\mathrm{ off}}$ ) of 106, an increased field-effect mobility ( $\mu $ ) of 6.5 cm2/Vs, a lower threshold voltage $(V_{\mathrm{ th}})$ of 0.2 V, and a low operating voltage of 3 V. These results are superior to the IGZO TFTs with Al2O3 dielectrics deposited using the single TMA/H2O cycle. Therefore, the implementation of ‘double cycles’ in the fabrication of dielectrics through ALD demonstrates considerable potential for future application in low-power electronic devices.

Dual In-Plane-Gate Oxide-Based Thin-Film Transistors with Tunable Threshold Voltage

Tuning the Threshold Voltage of Double-Gate Low-Voltage Transparent Oxide-Based Tfts by A Lateral In-Plane Gate

Low-Voltage Oxide-Based Tfts Self-Assembled on Paper Substrates with Tunable Threshold Voltage

Self-Assembled In-Plane Gate Oxide-Based Homojunction Thin-Film Transistors

In-Plane-Gate Indium-Tin-Oxide Thin-Film Transistors Self-Assembled on Paper Substrates

Flexible Dual-Gate Oxide TFTs Gated by Chitosan Film on Paper Substrates

Vertical Oxide Homojunction TFTs of 0.8 V Gated by $ \hbox{h}_{3}\hbox{po}_{4}$ -Treated $\hbox{sio}_{2}$ Nanogranular Dielectric

Low-Voltage Junctionless Oxide-Based Thin-Film Transistors Self-Assembled by A Gradient Shadow Mask

In-Plane-Gate Oxide-Based Thin-Film Transistors Self-Aligned on Stacked Self-Assembled Monolayer/$\hbox{SiO}_{2}$ Electrolyte Dielectrics

Self-Assembled Ultralow-Voltage Flexible Transparent Thin-Film Transistors Gated By Sio2-Based Solid Electrolyte

Low-Voltage Transparent Indium–Zinc–Oxide Coplanar Homojunction TFTs Self-Assembled on Inorganic Proton Conductors

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al₂O₃ Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

Dynamic Threshold Voltage Modulation in Double-Gate Indium-Gallium-Zinc Oxide Thin-Film Transistors: Influence of the Active Layer Thickness

Junctionless Flexible Oxide-Based Thin-Film Transistors on Paper Substrates

Threshold Voltage Control in Dual-Gate Organic Electrochemical Transistors

High Mobility Metal-Oxide Thin Film Transistors with IGZO/In2O3 Dual-Channel Structure

Lateral-coupling coplanar-gate oxide-based thin-film transistors on bare paper substrates

Transparent Junctionless Thin-Film Transistors with Tunable Operation Mode

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al2O3 Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

A ternary gate-connected threshold switching thin-film transistor

Dual-gate low-voltage transparent electric-double-layer thin-film transistors with a top gate for threshold voltage modulation