Abstract:High-quality ZnO films were grown on Si(1 0 0) substrates with low-temperature (LT) ZnO buffer layers by an electron cyclotron resonance (ECR)-assisted molecular-beam epitaxy (MBE). In order to investigate the optimized buffer layer temperature, ZnO buffer layers of about 1.1 μm were grown at different growth temperatures of 350, 450 and 550 °C, followed by identical high-temperature (HT) ZnO films with the thickness of 0.7 μm at 550 °C. A ZnO buffer layer with a growth temperature of 450 °C (450 °C-buffer sample) was found to greatly enhance the crystalline quality of the top ZnO film compared to others. The root mean square (RMS) roughness (3.3 nm) of its surface is the smallest, compared to the 350 °C-buffer sample (6.7 nm), the 550 °C-buffer sample (7.4 nm), and the sample without a buffer layer (6.8 nm). X-ray diffraction (XRD), photoluminescence (PL) and Raman scattering measurements were carried out on these samples at room temperature (RT) in order to characterize the crystalline quality of ZnO films. The preferential c-axis orientations of (0 0 2) ZnO were observed in the XRD spectra. The full-width at half-maximum (FWHM) value of the 450 °C-buffer sample was the narrowest as 0.209°, which indicated that the ZnO film with a buffer layer grown at this temperature was better for the subsequent ZnO growth at elevated temperature of 550 °C. Consistent with these results, the 450 °C-buffer sample exhibits the highest intensity and the smallest FWHM (130 meV) of the ultraviolet (UV) emission at 375 nm in the PL spectrum. The ZnO characteristic peak at 438.6 cm−1 was found in Raman scattering spectra for all films with buffers, which is corresponding to the E2 mode.

Improvement of the crystallinity and optical properties of sol-gel ZnO thin film by a PVD ZnO buffer layer

Effect of the ZnO buffer layer thickness on AZO film properties

Effect of Solution Concentrations on Crystal Structure, Surface Topographies and Photoluminescence Properties of ZnO Thin Films

Microstructue and Optical Properties of Mg-doped ZnO Thin Films Prepared by Sol-gel Method

Preparation and Characterization of Mg-doped ZnO Thin Films by Sol–gel Method

Effect of solution concentration on surface morphology, optical properties and solar light response of ZnO thin films

Surface Topography and Optical Properties of Al-doped ZnO Thin Films by Sol-gel Process

Enhanced photo-induced hydrophilicity of the sol-gel-derived ZnO thin films by Na-doping

Improved N–Al Codoped P-Type ZnO Thin Films by Introduction of a Homo-Buffer Layer

ZnO growth on Si with low-temperature CdO and ZnO buffer layers by molecular-beam epitaxy

Influence of buffer layer on optoelectronic properties of B-Mg co-doped ZnO ultrathin film for high-performance transparent conductor application

Effects of oxide buffer layers on the microstructure and electrical properties of PLZST 2/87/10/3 antiferroelectric thin films

Synthesis and Characterization of Al–N Codoped P-Type ZnO Epitaxial Films Using High-Temperature Homo-Buffer Layer

ZnO Growth on Si with Low-Temperature ZnO Buffer Layers by ECR-assisted MBE

Sol-Gel Preparation of Ag/ZnO Films and Their Electrical and Optical Properties

Investigation on the Structural and Optical Properties of ZnO Thin Films Prepared by Sol-Gel Method

Effect of Mg Content and Buffer Layer on Properties of ZnMgO: Ga Thin Films

Low-temperature MOVPE Growth of ZnO Thin Films by Using a Buffer Layer

Influence of Buffer Layers on the Piezoelectric Property of ZnO Film

Polymer-assisted chemical solution deposition for the preparation of BaZrO 3 (BZO) buffer layer for coated conductors

Room-temperature growth and optoelectronic properties of GZO/ZnO bilayer films on polycarbonate substrates by magnetron sputtering