Abstract:High-quality ZnO films were grown on Si(1 0 0) substrates with low-temperature (LT) ZnO buffer layers by an electron cyclotron resonance (ECR)-assisted molecular-beam epitaxy (MBE). In order to investigate the optimized buffer layer temperature, ZnO buffer layers of about 1.1 μm were grown at different growth temperatures of 350, 450 and 550 °C, followed by identical high-temperature (HT) ZnO films with the thickness of 0.7 μm at 550 °C. A ZnO buffer layer with a growth temperature of 450 °C (450 °C-buffer sample) was found to greatly enhance the crystalline quality of the top ZnO film compared to others. The root mean square (RMS) roughness (3.3 nm) of its surface is the smallest, compared to the 350 °C-buffer sample (6.7 nm), the 550 °C-buffer sample (7.4 nm), and the sample without a buffer layer (6.8 nm). X-ray diffraction (XRD), photoluminescence (PL) and Raman scattering measurements were carried out on these samples at room temperature (RT) in order to characterize the crystalline quality of ZnO films. The preferential c-axis orientations of (0 0 2) ZnO were observed in the XRD spectra. The full-width at half-maximum (FWHM) value of the 450 °C-buffer sample was the narrowest as 0.209°, which indicated that the ZnO film with a buffer layer grown at this temperature was better for the subsequent ZnO growth at elevated temperature of 550 °C. Consistent with these results, the 450 °C-buffer sample exhibits the highest intensity and the smallest FWHM (130 meV) of the ultraviolet (UV) emission at 375 nm in the PL spectrum. The ZnO characteristic peak at 438.6 cm−1 was found in Raman scattering spectra for all films with buffers, which is corresponding to the E2 mode.

Low-temperature MOVPE Growth of ZnO Thin Films by Using a Buffer Layer

Effect of Nucleation and Growth Kinetics on the Electrical and Optical Properties of Undoped ZnO Films

STRUCTURAL AND OPTICAL STUDIES OF ZnO FILMS GROWN AT LOW TEMPERATURE

The Effects of Oxygen Partial Pressure and Substrate Temperature on the Structural and Optical Properties of Zno Films

Comparison of Structural and Optical Properties of ZnO Films Grown on Different Substrates at Low Temperatures

ZnO growth on Si with low-temperature CdO and ZnO buffer layers by molecular-beam epitaxy

Zno-based Thin Films Synthesized by Atmospheric Pressure Mist Chemical Vapor Deposition

Low-temperature epitaxy of ZnO films on Si(0 0 1) and silica by reactive e-beam evaporation

Low‐Temperature Growth of P‐type ZnO Thin Films Via Plasma‐Assisted MOCVD

ZnO Growth on Si with Low-Temperature ZnO Buffer Layers by ECR-assisted MBE

Epitaxial Growth Of Zno On Gan/Sapphire Substrate By Radio-Frequency Magnetron Sputtering

Low-Temperature Epitaxy Of Zno Films On Si(001) And Silica By Reactive E-Beam Evaporation

Structural and Optical Characterizations of ZnO Films Grown by Reactive Electron Beam Evaporation

Effect of the ZnO buffer layer thickness on AZO film properties

Effect of Low Temperature Thin GaN Layer on ZnO Film Grown on Nitridated c-Sapphire by Molecular Beam Epitaxy

Non-polar A-Plane ZnO Films Grown on R-Al2o3 Substrates Using GaN Buffer Layers

MBE‐grown ZnO Film on Sapphire Substrate with Double Buffer Layers

Growth of high-quality ZnO thin films on (11\bar{2}0) a-plane sapphire substrates by plasma-assisted molecular beam epitaxy

Growth of High-Quality ZnO Thin Films on ( 112̅0 ) A-Plane Sapphire Substrates by Plasma-Assisted Molecular Beam Epitaxy

Structure of Nanometer ZnO Films Grown at Low Temperature

Effect of Growth and Annealing on ZnO Buffer by MOCVD