Abstract:The gallium–magnesium codoped zinc oxide (GMZO) thin films were deposited on glass substrates by radio frequency magnetron sputtering technique in an argon atmosphere. The influence of substrate temperature on the microstructure, morphology and optoelectronic properties of thin films was investigated by X-ray diffraction, scanning electron microscopy, X-ray photoelectron spectroscopy, four-point probe and spectrophotometry. It is found that all the deposited films have a hexagonal structure and a preferred orientation along the c-axis perpendicular to the substrate. As the substrate temperature increases, the dislocation density, lattice strain and electrical resistivity decrease initially and then increase, while the average crystallite size, average visible transmittance and figure of merit exhibit the reverse variation trend. The GMZO thin film deposited at the substrate temperature of 570 K possesses the best optoelectronic properties, with the largest average crystallite size of 52.05 nm, the lowest dislocation density of 3.69 × 1014 lines m− 2, the minimum lattice strain of 1.10 × 10− 3, the lowest electrical resistivity of 1.62 × 10− 3 Ω cm, the highest average visible transmittance of 88.63% and the maximum figure of merit of 5.11 × 103 Ω−1 cm− 1. The optical energy gaps of the films were evaluated by extrapolation method and observed to be in the range of 3.34–3.55 eV. Furthermore, the complex refractive index, the complex dielectric constant and the dissipation factor were determined by optical characterization methods, and the dispersion behaviour of refractive index was studied in terms of the single electronic oscillator model. The results show that the microstructure and optoelectronic properties of the GMZO thin films are dependent on substrate temperature.

Room-temperature growth and optoelectronic properties of GZO/ZnO bilayer films on polycarbonate substrates by magnetron sputtering

Transparent and conductive Ga-doped ZnO films grown by RF magnetron sputtering on polycarbonate substrates

Study on the Structural, Electrical, Optical, Adhesive Properties and Stability of Ga-Doped Zno Transparent Conductive Films Deposited on Polymer Substrates at Room Temperature

Deposition and Characterization of AZO Thin Films on Flexible Glass Substrates Using DC Magnetron Sputtering Technique

Room-Temperature Growth and Properties of Transparent Conductive GZO/Cu/GZO Multilayer Thin Films

Fabrication and Properties of Transparent Conductive AZO/Cu Bilayer Films

The Effects of Oxygen Partial Pressure and Substrate Temperature on the Structural and Optical Properties of Zno Films

Conductive Ga doped ZnO/Cu/Ga doped ZnO thin films prepared by magnetron sputtering at room temperature for flexible electronics

Transparent Conductive and Near-Infrared Reflective Ga-doped ZnO/Cu Bilayer Films Grown at Room Temperature

Influence of ZnO buffer layer on the electrical, optical and surface properties of Ga-doped ZnO films

Transparent conductive Ga-doped ZnO/Cu multilayers prepared on polymer substrates at room temperature

Development of Transparent Oxide Thin Films for Flexible Devices

Improvement of Transparent Conductive Properties of GZO/Cu/GZO Tri-Layer Films by Introducing H2 into Sputtering Atmosphere

Highly Transparent Conductive F-doped ZnO Films in Wide Range of Visible and Near Infrared Wavelength Deposited on Polycarbonate Substrates

Transparent conductive Al-doped ZnO/Cu bilayer films grown on polymer substrates at room temperature

Investigation of the Structural, Electrical, and Optical Properties of the Nano-Scale GZO Thin Films on Glass and Flexible Polyimide Substrates

Effect of the ZnO buffer layer thickness on AZO film properties

Influence of buffer layer on optoelectronic properties of B-Mg co-doped ZnO ultrathin film for high-performance transparent conductor application

Influences of the RF power ratio on the optical and electrical properties of GZO thin films by DC coupled RF magnetron sputtering at room temperature

Growth and Characterization of High Transmittance GZO Films Prepared by Sol-Gel Method

Microstructure and optoelectronic properties of gallium–magnesium codoped zinc oxide thin films by magnetron sputtering technique