Abstract:Fly ashes,obtained from three commercial CFB boilers with burning Fujian anthracites,were studied in this paper.By using standard dry-sieving techniques and LOI method,the size distributions of fly ashes and the carbon contents of different size fractions were measured.With the help of SEM and EDX technique,the particle superficial property of fly ash was examined and divided into carbon(soot,or graphite),char,and slag.The residual carbon was enriched from fly ash by the floating-separation technique,and its reactivity was then measured via a non-isothermal TGA experiment.The results was compared with that of its corresponding parent coal.Furthermore,in a laboratory pilot scale fluidized bed furnace,the source of the unburned carbon in the fly ash was explored.It is shown that for CFB boilers using a single cyclone separator,the largest amount of fly ash particles lies in the particle size range from 0.0385mm to 0.0500mm,and so does the unburned carbon fraction;and for CFB boiler equipped with two separators,the largest amount of fly ash particles and unburned carbon fraction lies in a particle size range of 0.0500mm~0.0750mm.There are three kinds of particles existing in fly ashes,which are granular unburned carbon,flocculent slag and char.The reactivity of the unburned carbon in fly ashes is relatively higher than that of its parent feeding coal.It can be induced from this study that the unburned carbon in fly ashes comes primarily from the fines existed in the fed coal and produced by the attrition and fragmentation of coal particles,which cannot be totally burned in the earlier stage of combustion.The clarain,which is of high reactivity and frangible,may be the main originations of unburned carbon in fly ash.

A Study of the Reactivity and Formation of the Unburnt Carbon in CFB Fly Ashes

Mechanism on the Contribution of Coal/char Fragmentation to Fly Ash Formation During Pulverized Coal Combustion

Carbon Formation Mechanism in Fly Ash of Circulating Fluidized Bed Boilers

Characterization of fly ash and unburned carbon from CFB boiler with burning Fujian anthracite

Unburned Carbon Loss in Fly Ash of CFB Boilers Burning Hard Coal

Research on Carbon Content in Fly Ash from Circulating Fluidized Bed Boilers

Fly Ash and Coal Char Reactivity from Thermo-gravimetric (TGA) Experiments

EXPERIMENTAL RESEARCH ON COMBUSTION CHARACTERISTICS OF RESIDUAL CARBON OF FLY ASH FROM CFB BOILER

Raman Spectroscopy and X-Ray Diffraction Analysis of the Structural Characteristics of Fluidized Bed Gasification Fly Ash

Experimental and Kinetics Studies on the Evolution and Effects of Ash Film During Pulverized Coal Char Combustion

Pore Development and Combustion Behavior of Gasified Semi-Char in a Drop Tube Furnace

Experimental Study on the Improvement of Char Physicochemical Properties and Reactivity by Activation Process in CFB

Catalytic Effect Of Mineral Matter On Char Reactivity Under Cfbc Temperature Condition

Modeling Research On Char Particle Combustion Behavior In Cfb Condition

Structure characteristics and gasification activity of residual carbon from updraft fixed-bed biomass gasification ash

Differences in Gasification Behaviors and Related Properties between Entrained Gasifier Fly Ash and Coal Char

Study on Pore and Chemical Structure Characteristics of Atmospheric Circulating Fluidized Bed Coal Gasification Fly Ash

Fly Ash Reburn To Enhance The Combustion Efficiency Of Cfb Boiler Burning Fujian Anthracite

Experimental Investigation On Three Coals Ash Formation

Unburned Carbon Content in Fly Ash Forecast Modle Based on Combustion and Heat Transfer

Study on the structure characteristics and gasification activity of residual carbon in biomass ashes obtained from different gasification technologies