Abstract:Biomass char produced from pyrolysis processes is of great interest to be utilized as renewable solid fuels or materials. Forest byproducts and agricultural wastes are low-cost and sustainable biomass feedstocks. These biomasses generally contain high amounts of ash-forming elements, generally leading to high char reactivity. This study elaborates in detail how chemical and physical properties affect CO2 gasification rates of high-ash biomass char, and it also targets the interactions between these properties. Char produced from pine bark, forest residue, and corncobs (particle size 4-30 mm) were included, and all contained different relative compositions of ash-forming elements. Acid leaching was applied to further investigate the influence of inorganic elements in these biomasses. The char properties relevant to the gasification rate were analyzed, that is, elemental composition, specific surface area, and carbon structure. Gasification rates were measured at an isothermal condition of 800 °C with 20% (vol.) of CO2 in N2. The results showed that the inorganic content, particularly K, had a stronger effect on gasification reactivity than specific surface area and aromatic cluster size of the char. At the gasification condition utilized in this study, K could volatilize and mobilize through the char surface, resulting in high gasification reactivity. Meanwhile, the mobilization of Ca did not occur at the low temperature applied, thus resulting in its low catalytic effect. This implies that the dispersion of these inorganic elements through char particles is an important reason behind their catalytic activity. Upon leaching by diluted acetic acid, the K content of these biomasses substantially decreased, while most of the Ca remained in the biomasses. With a low K content in leached biomass char, char reactivity was determined by the active carbon surface area.

Study on the structure characteristics and gasification activity of residual carbon in biomass ashes obtained from different gasification technologies

Structure characteristics and gasification activity of residual carbon from updraft fixed-bed biomass gasification ash

Investigation on Effect of Coal Fly Ash on Properties of Corn Straw Pyrolysis Products

Gasification of the Char Residues with High Ash Content by Carbon Dioxide

Experimental study on thermal modification characteristics of entrained-flow gasified fine ash using circulating fluidized bed

Co-gasification of Acid Hydrolysis Residues and Sewage Sludge in a Downdraft Fixed Gasifier with CaO As an In-Bed Additive

Experimental Research of Basic Properties and Reactivity of Waste Derived Chars

Comparison of Gasification Performances Between Raw and Torrefied Biomasses in an Air-Blown Fluidized-Bed Gasifier

Effect of Air Equivalence Ratio on the Characteristics of Biomass Partial Gasification for Syngas and Biochar Co-Production in the Fluidized Bed

CO 2 Gasification Reactivity of Char from High-Ash Biomass

Resource utilization of gasified fine ash from entrained flow bed via thermal modification-melting combustion: A pilot study

A novel reutilization of ash from biomass gasification process: Feasibility and products improvement analysis

Influence of Coal Ash on the Characteristics of Corn Straw Pyrolysis Products.

Insight into the Relationship Between CO2 Gasification Characteristics and Char Structure of Biomass

A Study of the Reactivity and Formation of the Unburnt Carbon in CFB Fly Ashes

Influences of Ash-Existing Environments and Coal Structures on CO2 Gasification Characteristics of Tri-High Coal

Research on Carbon Content in Fly Ash from Circulating Fluidized Bed Boilers

Biomass gasification ash reutilization: Recirculation reusability and mechanism analysis

Structure characteristics and gasification activity of residual carbon from entrained-flow coal gasification slag

A comparative study on the intrinsic reactivity and structural evolution during gasification of chars from biomass and different rank coals

An experimental investigation into bed particle agglomeration and ash deposition during circulating fluidized bed gasification of Zhundong lignite