Abstract:Fly ashes,obtained from three commercial CFB boilers with burning Fujian anthracites,were studied in this paper.By using standard dry-sieving techniques and LOI method,the size distributions of fly ashes and the carbon contents of different size fractions were measured.With the help of SEM and EDX technique,the particle superficial property of fly ash was examined and divided into carbon(soot,or graphite),char,and slag.The residual carbon was enriched from fly ash by the floating-separation technique,and its reactivity was then measured via a non-isothermal TGA experiment.The results was compared with that of its corresponding parent coal.Furthermore,in a laboratory pilot scale fluidized bed furnace,the source of the unburned carbon in the fly ash was explored.It is shown that for CFB boilers using a single cyclone separator,the largest amount of fly ash particles lies in the particle size range from 0.0385mm to 0.0500mm,and so does the unburned carbon fraction;and for CFB boiler equipped with two separators,the largest amount of fly ash particles and unburned carbon fraction lies in a particle size range of 0.0500mm~0.0750mm.There are three kinds of particles existing in fly ashes,which are granular unburned carbon,flocculent slag and char.The reactivity of the unburned carbon in fly ashes is relatively higher than that of its parent feeding coal.It can be induced from this study that the unburned carbon in fly ashes comes primarily from the fines existed in the fed coal and produced by the attrition and fragmentation of coal particles,which cannot be totally burned in the earlier stage of combustion.The clarain,which is of high reactivity and frangible,may be the main originations of unburned carbon in fly ash.

Carbon Formation Mechanism in Fly Ash of Circulating Fluidized Bed Boilers

Research on Carbon Content in Fly Ash from Circulating Fluidized Bed Boilers

A Study of the Reactivity and Formation of the Unburnt Carbon in CFB Fly Ashes

Unburned Carbon Loss in Fly Ash of CFB Boilers Burning Hard Coal

Mechanism on the Contribution of Coal/char Fragmentation to Fly Ash Formation During Pulverized Coal Combustion

A general mechanistic model of fly ash formation during pulverized coal combustion

Characterization of fly ash and unburned carbon from CFB boiler with burning Fujian anthracite

Coal combustion efficiency in CFB boiler

Modeling Research On Char Particle Combustion Behavior In Cfb Condition

Reducing the Combustible in Fly Ash of Circulating Fluidized Bed Boiler

EXPERIMENTAL RESEARCH ON COMBUSTION CHARACTERISTICS OF RESIDUAL CARBON OF FLY ASH FROM CFB BOILER

Experiments on Ash Formation of Different Coals in Circulating Fluidized Bed Combustion

Study on Characteristics of CFBB Desulfurated Fly Ash and Pulverized Fly Ash

Coal Combustion Efficiency in Circulation Fluidized Bed

Experimental Investigation On Three Coals Ash Formation

EXPERIMENTAL TECHNIQUE ON COAL ASH FORMATION IN CFB COMBUSTION

Characteristics of Fly Ash Recycle to Reburn in Circulating Fluidized Bed Boilers

Investigation of Ash Deposition Dynamic Process in an Industrial Biomass CFB Boiler Burning High-Alkali and Low-Chlorine Fuel

Non-linear Characteristics on Carbon Content of Fly Ash for Different Size Particles in Pulverized Coal Boiler

Desulfurization Characteristics of Fly Ash Recirculation and Combustion in the Circulating Fluidized Bed Boiler

Resident Time of Combustion Products and its Effect on Carbon Content in Fly Ash in Pulverized Coal Fired Boilers