Abstract:Fly ashes,obtained from three commercial CFB boilers with burning Fujian anthracites,were studied in this paper.By using standard dry-sieving techniques and LOI method,the size distributions of fly ashes and the carbon contents of different size fractions were measured.With the help of SEM and EDX technique,the particle superficial property of fly ash was examined and divided into carbon(soot,or graphite),char,and slag.The residual carbon was enriched from fly ash by the floating-separation technique,and its reactivity was then measured via a non-isothermal TGA experiment.The results was compared with that of its corresponding parent coal.Furthermore,in a laboratory pilot scale fluidized bed furnace,the source of the unburned carbon in the fly ash was explored.It is shown that for CFB boilers using a single cyclone separator,the largest amount of fly ash particles lies in the particle size range from 0.0385mm to 0.0500mm,and so does the unburned carbon fraction;and for CFB boiler equipped with two separators,the largest amount of fly ash particles and unburned carbon fraction lies in a particle size range of 0.0500mm~0.0750mm.There are three kinds of particles existing in fly ashes,which are granular unburned carbon,flocculent slag and char.The reactivity of the unburned carbon in fly ashes is relatively higher than that of its parent feeding coal.It can be induced from this study that the unburned carbon in fly ashes comes primarily from the fines existed in the fed coal and produced by the attrition and fragmentation of coal particles,which cannot be totally burned in the earlier stage of combustion.The clarain,which is of high reactivity and frangible,may be the main originations of unburned carbon in fly ash.

Characteristics of Fly Ash Recycle to Reburn in Circulating Fluidized Bed Boilers

Desulfurization Characteristics of Fly Ash Recirculation and Combustion in the Circulating Fluidized Bed Boiler

The Experimental Study of Fly Ash Recirculation Combustion Characteristics on a Circulating Fluidized Bed Combustor

Fly Ash Reburn To Enhance The Combustion Efficiency Of Cfb Boiler Burning Fujian Anthracite

Research on Carbon Content in Fly Ash from Circulating Fluidized Bed Boilers

Experimental on Fly Ash Recirculation with Bottom Feeding to Improve the Performance of a Circulating Fluidized Bed Boiler Co-burning Coal Sludge

Reducing the Combustible in Fly Ash of Circulating Fluidized Bed Boiler

Study on Characteristics of CFBB Desulfurated Fly Ash and Pulverized Fly Ash

Fly ash recirculation by bottom feeding on a circulating fluidized bed boiler co-burning coal sludge and coal

Coal combustion efficiency in CFB boiler

Coal Combustion Characteristics on an Oxy-Fuel Circulating Fluidized Bed Combustor with Warm Flue Gas Recycle

Hydration and Desulphurization of Fly Ash of Circulating Fluidized Bed Boiler

Characterization of fly ash and unburned carbon from CFB boiler with burning Fujian anthracite

EXPERIMENTAL RESEARCH ON COMBUSTION CHARACTERISTICS OF RESIDUAL CARBON OF FLY ASH FROM CFB BOILER

Unburned Carbon Loss in Fly Ash of CFB Boilers Burning Hard Coal

Carbon Formation Mechanism in Fly Ash of Circulating Fluidized Bed Boilers

Enhanced combustion behavior and NO<sub>x</sub> reduction performance in a CFB combustor by combining flue gas recirculation with air-staging: Effect of injection position

C214 DEVELOPMENT OF UTILIZATION OF CFB BOILER ASH

Coal Combustion Efficiency in Circulation Fluidized Bed

Analysis of effects of fly ash reburning to particle deposition in boiler

Recent Advances in a Study on the Utilization of Circulating Fluidized Bed (CFB) Ash Residue