Abstract:Fly ashes,obtained from three commercial CFB boilers with burning Fujian anthracites,were studied in this paper.By using standard dry-sieving techniques and LOI method,the size distributions of fly ashes and the carbon contents of different size fractions were measured.With the help of SEM and EDX technique,the particle superficial property of fly ash was examined and divided into carbon(soot,or graphite),char,and slag.The residual carbon was enriched from fly ash by the floating-separation technique,and its reactivity was then measured via a non-isothermal TGA experiment.The results was compared with that of its corresponding parent coal.Furthermore,in a laboratory pilot scale fluidized bed furnace,the source of the unburned carbon in the fly ash was explored.It is shown that for CFB boilers using a single cyclone separator,the largest amount of fly ash particles lies in the particle size range from 0.0385mm to 0.0500mm,and so does the unburned carbon fraction;and for CFB boiler equipped with two separators,the largest amount of fly ash particles and unburned carbon fraction lies in a particle size range of 0.0500mm~0.0750mm.There are three kinds of particles existing in fly ashes,which are granular unburned carbon,flocculent slag and char.The reactivity of the unburned carbon in fly ashes is relatively higher than that of its parent feeding coal.It can be induced from this study that the unburned carbon in fly ashes comes primarily from the fines existed in the fed coal and produced by the attrition and fragmentation of coal particles,which cannot be totally burned in the earlier stage of combustion.The clarain,which is of high reactivity and frangible,may be the main originations of unburned carbon in fly ash.

Coal Combustion Efficiency in Circulation Fluidized Bed

Coal combustion efficiency in CFB boiler

Research on Carbon Content in Fly Ash from Circulating Fluidized Bed Boilers

STUDY ON CORRELATIVITY BETWEEN UNBURNED CARBON IN FLY ASH OF BOILERS AND THE COMBUSTION PROPERTIES OF COAL

The Fundamental Studies on Combustion of Sintering Flue Gas in Circulating Fluidized Bed

Unburned Carbon Loss in Fly Ash of CFB Boilers Burning Hard Coal

Experiments on Ash Formation of Different Coals in Circulating Fluidized Bed Combustion

Reducing the Combustible in Fly Ash of Circulating Fluidized Bed Boiler

Desulfurization Characteristics of Fly Ash Recirculation and Combustion in the Circulating Fluidized Bed Boiler

Theoretically Studies of the Coal Particle Cluster Combustion Behavior in a Circulating Fluidized Bed

Pollutant Emission and Attrition Performance of Low Calorific Blended Coals During Co-Combustion in Fluidized Bed

Investigation on self-sustained combustion, NOx emissions, and ash characteristics of coal slime in a lab-scale fluidized bed

The Investigation of the Coal Ignition Temperature and Ignition Characteristics in an Oxygen-Enriched FBR

Combustion Optimization Test and Result Analysis on 480 t/h Circulating Fluidized Bed Boiler

Carbon Formation Mechanism in Fly Ash of Circulating Fluidized Bed Boilers

Co-Combustion of Tannery Sludge in a Bench-Scale Fluidized-Bed Combustor: Gaseous Emissions and Cr Distribution and Speciation

Resident Time of Combustion Products and its Effect on Carbon Content in Fly Ash in Pulverized Coal Fired Boilers

CONVERSION OF THE MINERALS IN FLUIDIZED BED COMBUSTION

Combustion Experiment and Gray Relational Analysis of Coal Water Slurry Balls in Fluidized Bed

Combustion Behavior And So2, Nox Emissions Of An Anthracite Coal In A Circulating Fluidized Bed

Characterization of fly ash and unburned carbon from CFB boiler with burning Fujian anthracite