Abstract:Fly ashes,obtained from three commercial CFB boilers with burning Fujian anthracites,were studied in this paper.By using standard dry-sieving techniques and LOI method,the size distributions of fly ashes and the carbon contents of different size fractions were measured.With the help of SEM and EDX technique,the particle superficial property of fly ash was examined and divided into carbon(soot,or graphite),char,and slag.The residual carbon was enriched from fly ash by the floating-separation technique,and its reactivity was then measured via a non-isothermal TGA experiment.The results was compared with that of its corresponding parent coal.Furthermore,in a laboratory pilot scale fluidized bed furnace,the source of the unburned carbon in the fly ash was explored.It is shown that for CFB boilers using a single cyclone separator,the largest amount of fly ash particles lies in the particle size range from 0.0385mm to 0.0500mm,and so does the unburned carbon fraction;and for CFB boiler equipped with two separators,the largest amount of fly ash particles and unburned carbon fraction lies in a particle size range of 0.0500mm~0.0750mm.There are three kinds of particles existing in fly ashes,which are granular unburned carbon,flocculent slag and char.The reactivity of the unburned carbon in fly ashes is relatively higher than that of its parent feeding coal.It can be induced from this study that the unburned carbon in fly ashes comes primarily from the fines existed in the fed coal and produced by the attrition and fragmentation of coal particles,which cannot be totally burned in the earlier stage of combustion.The clarain,which is of high reactivity and frangible,may be the main originations of unburned carbon in fly ash.

STUDY ON CORRELATIVITY BETWEEN UNBURNED CARBON IN FLY ASH OF BOILERS AND THE COMBUSTION PROPERTIES OF COAL

Characteristics Experimental of Fly Ash Release in Combustion Process of Blended Coal

Study on the Variation of Coal Properties for Different Coal Diameters and Its Effects on Combustion Characteristics

Experimental Study of Effects of Pulverized Coal Characteristics on the Conversion of Fuel Nitrogen to NOx

PREDICTION OF BURNING BEHAVIOR FOR PULVERIZED COAL AND ITS APPLICATION ON PRACTICAL BOILERS

STUDY ON IMPROVEMENT OF BURNING BEHAVIOR FOR INDONESIAN COAL AND ITS APPLICATION ON 300 MW UNITS

Study on Coal Ash Fusion Characteristics with TG-DSC Method

Coal Combustion Efficiency in Circulation Fluidized Bed

Non-linear Characteristics on Carbon Content of Fly Ash for Different Size Particles in Pulverized Coal Boiler

Cause Analysis on High Carbon Content in Fly Ash of Boilers

Research on Combustion Characteristics of Mixed Fuels of Fly-Ash and Coal

Experimental Study On The Comprehensive Behavior Of Combustion For Blended Coals

Non-linear Relationship Between Combustion Kinetic Parameters and Coal Quality

Study on Ash Fusion Process of Blended Coal by TG-DSC

Research on Carbon Content in Fly Ash from Circulating Fluidized Bed Boilers

Study on Coal Combustion Features with Thermal Balance

A Study of the Correlation between the Carbon Content in Fly-ash of Coal-fired Power Plants and Adsorption Quantity of PAHs (Polycyclic Aromatic Hydrocarbons) Organic Pollutants

Resident Time of Combustion Products and its Effect on Carbon Content in Fly Ash in Pulverized Coal Fired Boilers

Investigations into the Ignition Behaviors of Pulverized Coals and Coal Blends in a Drop Tube Furnace Using Flame Monitoring Techniques

Characterization of fly ash and unburned carbon from CFB boiler with burning Fujian anthracite

The Investigation of Carbon Content in Fly Ash for a BP Neural Network-based Pulverized Coal-fired Boiler