Abstract:The flow temperature (FT) of the coal ash from the Liuqiao no. 2 mine in North Anhui Province (C00) is too high (∼1520 °C) to fit the Shell gasifier due to its relatively high content of SiO2 and Al2O3. To solve this problem, a series of coals were blended with C00 with different ratios, and the relations between FT and the ash composition were investigated. The coal ash was analyzed by X-ray diffraction, Fourier transform infrared (FTIR) spectroscopy, and scanning electron microscopy–EDX to elucidate the mechanism of the improved ash fusion performance and the slag formation in the waste heat boiler of the gasifier. It is shown that FT is relevant to the coal ash compositions as well as the structures formed at high temperatures. The existence of alkaline oxides (CaO, MgO, and Fe2O3) decreases the coal ash FT to a low level. The FT can decrease to <1350 °C to cater to the Shell gasifier by blending C00 and C03 with a mass ratio of 4:6 owing to the plentiful alkaline oxides in C03. The FTIR results indicate that the high flow temperature of C00 is attributed to the formation of mullite at high temperatures. The coal blending with various ratios changes the compositions of CaO, MgO, and Fe2O3, which can form some low-melting-point eutectic compounds with SiO2 and Al2O3 under high temperatures, inhibit the formation of mullite, and thus decrease the ash FT. The coal ash FT was found to have a good linear relation with the ash compositions, which can sever as a reference to the coal blending. According to the model parameters, it is shown that Mg has the most significant promoting effect on the decrease in FT of the coal ash. The caking tendency of fly ash increases with the rising Ca content and an excessive Ca-based fluxing agent used in the coal blending will lead to the aggregation of the Ca-rich clasts around the fly ash particle, resulting in the plugging of the waste heat boiler in the gasifier. Therefore, the Mg-based fluxing agent is more promising to improve the ash fusion performance and reduce the caking tendency of the coal fly ash.This article has not yet been cited by other publications.

Cause Analysis on High Carbon Content in Fly Ash of Boilers

Characteristics Experimental of Fly Ash Release in Combustion Process of Blended Coal

STUDY ON CORRELATIVITY BETWEEN UNBURNED CARBON IN FLY ASH OF BOILERS AND THE COMBUSTION PROPERTIES OF COAL

Research on Carbon Content in Fly Ash from Circulating Fluidized Bed Boilers

Mechanism on the Contribution of Coal/char Fragmentation to Fly Ash Formation During Pulverized Coal Combustion

Quantitative analysis of minerals of blended coal ash at high temperature and its influence on slagging

Non-linear Characteristics on Carbon Content of Fly Ash for Different Size Particles in Pulverized Coal Boiler

Characterization of fly ash and unburned carbon from CFB boiler with burning Fujian anthracite

Unburned Carbon Loss in Fly Ash of CFB Boilers Burning Hard Coal

Study on Coal Ash Fusion Characteristics with TG-DSC Method

Effect of Chemical Compositions on Ash Fusibility Characterization of a Jincheng Anthracite During Combustion and Gasification

Resident Time of Combustion Products and its Effect on Carbon Content in Fly Ash in Pulverized Coal Fired Boilers

The Investigation of Carbon Content in Fly Ash for a BP Neural Network-based Pulverized Coal-fired Boiler

A Study of the Correlation between the Carbon Content in Fly-ash of Coal-fired Power Plants and Adsorption Quantity of PAHs (Polycyclic Aromatic Hydrocarbons) Organic Pollutants

Fly Ash Reburn To Enhance The Combustion Efficiency Of Cfb Boiler Burning Fujian Anthracite

Research on the Dynamic Characteristic of Ash Deposition in Boilers Burning Coal and Coal Water Slurry

Influence of Ash Characteristics on Ash Deposition in Coal Fired Boiler

Melting Characteristics of Coal Ash and Properties of Fly Ash to Understand the Slag Formation in the Shell Gasifier

An Experimental Investigation into the Characteristics and Deposition Mechanism of High-Viscosity Coal Ash

Research on the Slagging Characteristics of Shenhua Coal

Analysis on the Reasons and Countermeasures of High Fly Ash Combustible and Low Mill Output in Power Plant