Abstract:Fly ashes,obtained from three commercial CFB boilers with burning Fujian anthracites,were studied in this paper.By using standard dry-sieving techniques and LOI method,the size distributions of fly ashes and the carbon contents of different size fractions were measured.With the help of SEM and EDX technique,the particle superficial property of fly ash was examined and divided into carbon(soot,or graphite),char,and slag.The residual carbon was enriched from fly ash by the floating-separation technique,and its reactivity was then measured via a non-isothermal TGA experiment.The results was compared with that of its corresponding parent coal.Furthermore,in a laboratory pilot scale fluidized bed furnace,the source of the unburned carbon in the fly ash was explored.It is shown that for CFB boilers using a single cyclone separator,the largest amount of fly ash particles lies in the particle size range from 0.0385mm to 0.0500mm,and so does the unburned carbon fraction;and for CFB boiler equipped with two separators,the largest amount of fly ash particles and unburned carbon fraction lies in a particle size range of 0.0500mm~0.0750mm.There are three kinds of particles existing in fly ashes,which are granular unburned carbon,flocculent slag and char.The reactivity of the unburned carbon in fly ashes is relatively higher than that of its parent feeding coal.It can be induced from this study that the unburned carbon in fly ashes comes primarily from the fines existed in the fed coal and produced by the attrition and fragmentation of coal particles,which cannot be totally burned in the earlier stage of combustion.The clarain,which is of high reactivity and frangible,may be the main originations of unburned carbon in fly ash.

Non-linear Characteristics on Carbon Content of Fly Ash for Different Size Particles in Pulverized Coal Boiler

Characteristics Experimental of Fly Ash Release in Combustion Process of Blended Coal

A general mechanistic model of fly ash formation during pulverized coal combustion

Mechanism on the Contribution of Coal/char Fragmentation to Fly Ash Formation During Pulverized Coal Combustion

Experimental Study of Effects of Pulverized Coal Characteristics on the Conversion of Fuel Nitrogen to NOx

STUDY ON CORRELATIVITY BETWEEN UNBURNED CARBON IN FLY ASH OF BOILERS AND THE COMBUSTION PROPERTIES OF COAL

Research on Carbon Content in Fly Ash from Circulating Fluidized Bed Boilers

Resident Time of Combustion Products and its Effect on Carbon Content in Fly Ash in Pulverized Coal Fired Boilers

The Investigation of Carbon Content in Fly Ash for a BP Neural Network-based Pulverized Coal-fired Boiler

Characterization of fly ash and unburned carbon from CFB boiler with burning Fujian anthracite

The Analysis of the Unburned Carbon in Fly Ash for Tangentially Pulverized Coal-Fired Boiler Based on Factor Analysis Method

EXPERIMENTAL RESEARCH ON COMBUSTION CHARACTERISTICS OF RESIDUAL CARBON OF FLY ASH FROM CFB BOILER

Cause Analysis on High Carbon Content in Fly Ash of Boilers

Experimental Study on the Porous Structure of Variously Sized Fly Ash Particles under Different Combustion Conditions

Characterization of Residual Carbon in Fly Ashes from Power Plants Firing Biomass

Numerical Study of Operation Parameters on Pulverized Coal Ignition and Unburned Carbon in Fly Ash for a Boiler

Carbon Formation Mechanism in Fly Ash of Circulating Fluidized Bed Boilers

Differences in Gasification Behaviors and Related Properties between Entrained Gasifier Fly Ash and Coal Char

Modeling Research On Char Particle Combustion Behavior In Cfb Condition

INVESTIGATION OF DUAL CHANNEL LOW NO_x PULVERIZED COAL COMBUSTOR FLY ASH CARBON FORMATION

Unburned Carbon Loss in Fly Ash of CFB Boilers Burning Hard Coal