Abstract:In this work, carrier-phase direct numerical simulation (CP-DNS) is conducted for a pulverized coal flame in a temporally evolving turbulent jet with flue gas recirculation (FGR). Detailed gas phase kinetics are considered and heavy hydrocarbon molecules up to C20 are included to accurately represent tars in the volatile matter. The structure of the pulverized coal flame is analyzed with different flamelet models considering two mixing scenarios, namely the mixing of recirculated flue gases with the other fuel or oxidizer streams. In the first model approach, the mixing of recirculated flue gases with the gaseous fuels released from the coal particle is characterized with a fuel-split-based flamelet (FLT-FS) model. In the second approach, the mixing of flue gases with the transport air is described with an oxidizer-split-based flamelet (FLT-OS) model. In total, five trajectory variables are introduced in the flamelet table to represent the pulverized coal combustion states with FGR. The suitability of the flamelet models is evaluated through an a priori analysis for both the fully ignited state, as well as (more challenging) the igniting states. Comparisons show that both the FLT-FS model and the FLT-OS model perform well in predicting the thermo-chemical quantities for the fully ignited state. The FLT-OS model performs slightly better than the FLT-FS model in predicting the gas temperature and specific species mass fractions. This is due to the fact that the partial oxidization of the gaseous fuels by the hot flue gases outside the mixing layers cannot be reproduced by the FLT-FS model. While the state at the beginning of ignition can still be accurately predicted by the FLT-OS model, discrepancies can be observed for the tar species C20H10 and the intermediate species CO at a later stage when many particles ignite and the reason for this is explained. Further analysis in the flamelet solution spaces shows that the gaseous fuels are ignited on the fuel-lean side. The time evolution of the gas temperature from the beginning of ignition to the fully ignited state can be overall characterized by both flamelet models.

Mechanism on the Contribution of Coal/char Fragmentation to Fly Ash Formation During Pulverized Coal Combustion

A general mechanistic model of fly ash formation during pulverized coal combustion

Ultrafine Particle Formation in Pulverized Coal, Biomass, and Waste Combustion: Understanding the Relationship with Flame Synthesis Process

Characteristics Experimental of Fly Ash Release in Combustion Process of Blended Coal

Ultrafine particulate matter formation in the early stage of pulverized coal combustion of high-sodium lignite

Characteristics Of Submicron Particulate Matters Formed In The Early Stage Of Oxy-Fuel Coal Combustion

Measurement and Numerical Simulation of Ultrafine Particle Size Distribution in the Early Stage of High-Sodium Lignite Combustion

Flame Structure Analysis and Flamelet Modeling of Turbulent Pulverized Solid Fuel Combustion with Flue Gas Recirculation

Fragmentation Behavior of the Large Particles during Coal Combustion in Fluidized Bed

The Influence of Pore Distribution of Coal Char in the Char Fragmentation and Included Minerals Partitioning: A Percolation Modeling

Primary Fragmentation Behavior Investigation in Pulverized Coal Combustion with High-Speed Digital Inline Holography

Dynamic Evolution of Impaction and Sticking Behaviors of Fly Ash Particle in Pulverized Coal Combustion

Kinetic Study on Co-Combustion of Pulverized Anthracite and Bituminite for Blast Furnace Injection

Investigating Particle and Volatile Evolution During Pulverized Coal Combustion Using High-Speed Digital In-Line Holography

Study on the formation of PM 10 from high-sodium coal under gasification conditions in a flat-flame burner reactor

A Survey of the Research Findings Concerning the Thermal Fragmentation Phenomena of Anthracite During its Combustion in a Fluidized Bed

The Fragmentation of Coal Particles During the Coal Combustion in a Fluidized Bed

Experimental Research On The Fragmentation Of Long-Yan Anthracite With Different Lithotypes In Fluidized Bed Combustion

Modeling the Process and Properties of Ash Formation during Pulverized Biomass Combustion

Fine Particulate Formation And Ash Deposit Behavior During Sawdust/Coal Co-Firing

Numerical and Experimental Study on the Deposition of Fine Particulate Matter During the Combustion of Pulverized Lignite Coal in a 25 Kw Combustor