Abstract:Fly ashes,obtained from three commercial CFB boilers with burning Fujian anthracites,were studied in this paper.By using standard dry-sieving techniques and LOI method,the size distributions of fly ashes and the carbon contents of different size fractions were measured.With the help of SEM and EDX technique,the particle superficial property of fly ash was examined and divided into carbon(soot,or graphite),char,and slag.The residual carbon was enriched from fly ash by the floating-separation technique,and its reactivity was then measured via a non-isothermal TGA experiment.The results was compared with that of its corresponding parent coal.Furthermore,in a laboratory pilot scale fluidized bed furnace,the source of the unburned carbon in the fly ash was explored.It is shown that for CFB boilers using a single cyclone separator,the largest amount of fly ash particles lies in the particle size range from 0.0385mm to 0.0500mm,and so does the unburned carbon fraction;and for CFB boiler equipped with two separators,the largest amount of fly ash particles and unburned carbon fraction lies in a particle size range of 0.0500mm~0.0750mm.There are three kinds of particles existing in fly ashes,which are granular unburned carbon,flocculent slag and char.The reactivity of the unburned carbon in fly ashes is relatively higher than that of its parent feeding coal.It can be induced from this study that the unburned carbon in fly ashes comes primarily from the fines existed in the fed coal and produced by the attrition and fragmentation of coal particles,which cannot be totally burned in the earlier stage of combustion.The clarain,which is of high reactivity and frangible,may be the main originations of unburned carbon in fly ash.

EXPERIMENTAL TECHNIQUE ON COAL ASH FORMATION IN CFB COMBUSTION

Experimental Investigation On Three Coals Ash Formation

Investigation on the Ash Size Distribution and Attrition During the Coal Combustion in Fluidized Bed

Semi-empirical Technique for Predicting Ash Size Distribution in CFB Boilers

Experiments on Ash Formation of Different Coals in Circulating Fluidized Bed Combustion

Coal combustion efficiency in CFB boiler

A six-parameter model to predict ash formation in a CFB boiler

Research on Carbon Content in Fly Ash from Circulating Fluidized Bed Boilers

EXPERIMENTAL STUDY OF ASH DEPOSIT DURING CO-FIRING SAWDUST AND COAL

TEST STUDY ON THE INFLUENCE OF COAL PARTICLE SIZE UPON ASH-SLAG FORMATION IN CFB BOILERS

Carbon Formation Mechanism in Fly Ash of Circulating Fluidized Bed Boilers

KINETIC ANALYSIS AND EXPERIMENTAL STUDY ON FORMATION MECHANISM OF COAL ASH MINERALS AT HIGH CALCIUM CONTENT IN PCC BOILERS

Characterization of fly ash and unburned carbon from CFB boiler with burning Fujian anthracite

C214 DEVELOPMENT OF UTILIZATION OF CFB BOILER ASH

Model Research On Material Balance In A Circulating Fluidized Bed Boiler

Experimental study on ash deposition and corrosion in a CFB boiler co-firing biomass with coal

Investigation of Ash Deposition Dynamic Process in an Industrial Biomass CFB Boiler Burning High-Alkali and Low-Chlorine Fuel

Experimental Study And Analysis Of Coal Combustion On A Cfb Test-Facility In O-2/Co2 And O-2/N-2 Mixtures

Effect of Coal Ash on NOx Emission of CFB Boilers

Fly Ash Reburn To Enhance The Combustion Efficiency Of Cfb Boiler Burning Fujian Anthracite

Experimental Research of Igniting Characteristics in Circulating Fluidized Bed