Abstract:Ash aerosol and ash deposit formation during oxy-coal combustion were explored through experiments in a self-sustained 100kW rated down-fired oxy-fuel combustor. Inlet oxidant conditions consisted of 50% inlet oxygen with CO2 (hereafter denoted as OXY50 conditions). A Berner low pressure impactor (BLPI), a scanning mobility particle sizer (SMPS), and an aerodynamic particle sizer (APS) were used to obtain size segregated ash aerosol samples and to determine the particle size distributions (PSD). A novel surface temperature controlled ash deposition probe system that allowed inside and outside deposits to be separated was used to collect the ash deposits. The ash aerosol PSDs given by the BLPI and those produced by SMPS/APS were consistent with each other. Data suggested that oxy-coal combustion under these conditions did not change the formation mechanisms controlling the bulk ash aerosol composition, but it did increase the formation of ultra-fine particles initially formed through metal vaporization, due to increased vaporization of silicon at the higher combustion temperature. The smaller particles contained within the deposits had higher Si and lower Na and S concentrations under OXY50 conditions than for air combustion. Moreover, the ash aerosol composition for particle sizes less than 2.4μm was related to the composition of the inside deposits. A higher Na in the ash aerosol resulted in higher Na in inside deposits with comparable absolute Na concentrations in both those aerosol particles and those inside deposits particles. The contribution of S and Si to the inside deposits showed that S in the vaporization modes together with Si in the ultrafine vaporization mode, contributed significantly to the composition of the inside deposits. These results provided direct evidence that prediction of the chemistry of the initial deposit layer (but not of the bulk deposits) required knowledge of the size segregated chemistry of the ash aerosol.

EXPERIMENTAL STUDY OF ASH DEPOSIT DURING CO-FIRING SAWDUST AND COAL

Dynamic behavior of biomass ash deposition in a 25 kW one-dimensional down-fired combustor

Fine Particulate Formation And Ash Deposit Behavior During Sawdust/Coal Co-Firing

Experimental study on ash deposition and corrosion in a CFB boiler co-firing biomass with coal

Effect of co-firing straw with two coals on the ash deposition behavior in a down-fired pulverized coal combustor

Co-firing biomass with coal on ash deposition behavior at various temperatures in a Down-Fired furnace

The electron microscopy study of ash deposition in the pulverized-coal burned

Research on the Dynamic Characteristic of Ash Deposition in Boilers Burning Coal and Coal Water Slurry

Ash Deposition Behavior under Coal and Wood Co-Firing Conditions in a 300 Kw Downfired Furnace

Influence of Ash Characteristics on Ash Deposition in Coal Fired Boiler

In Situ Diagnostics on the Dynamic Processes of Ash Deposit Formation, Shedding, and Heat Transfer in a Self-Sustained Down-Fired Furnace

An Experimental Investigation into the Characteristics and Deposition Mechanism of High-Viscosity Coal Ash

Ash Aerosol Formation from Oxy-Coal Combustion and Its Relation to Ash Deposit Chemistry

Investigation of Ash Deposition Dynamic Process in an Industrial Biomass CFB Boiler Burning High-Alkali and Low-Chlorine Fuel

Investigation of Ash Deposition Characteristics in Full-Scale Circulating Fluidized Bed Boiler Burning Zhundong Coal

Ash Deposition of Zhundong Coal in a 350 MW Pulverized Coal Furnace: Influence of Sulfation

Behavior of Slagging Deposits During Coal and Biomass Co-combustion in a 300 Kw Down-Fired Furnace

Numerical and Experimental Study on the Deposition of Fine Particulate Matter During the Combustion of Pulverized Lignite Coal in a 25 Kw Combustor

Experimental Investigation of Ash Deposits Characteristics of Co-Combustion of Coal and Rice Hull Using a Digital Image Technique

Ash Deposition Mechanism and Composition Distribution Characteristics in Oil-fired Boiler

Effect of Coal-water Slurry Reburning on Ash Deposition in Boiler