Ash Deposition of Zhundong Coal in a 350 MW Pulverized Coal Furnace: Influence of Sulfation

Hang Shi,Yuxin Wu,Man Zhang,Yang Zhang,Junfu Lyu
DOI: https://doi.org/10.1016/j.fuel.2019.116317
IF: 7.4
2020-01-01
Fuel
Abstract:The huge reserve of Zhundong (ZD) coal makes it important for energy utilization of China. However, big concerns on fouling and slagging in pulverized coal-firing boilers were risen due to its high alkali content. It's important to investigate deposition in different heating surfaces of a boiler burning ZD coal. In this paper, XRF, XRD, ICP-OES were conducted to analyze the properties of ash deposits collected from different heating surfaces in a 350 MW boiler burning 30% Wudong (WD) and 70% Wucaiwan (WCW) coals. Thermodynamics calculations were applied to study the mineral composition of coal ash in the range of 200-1600 degrees C under different coal co-firing ratio. The analytical results of the ash deposits showed that in medium-temperature (800-1100 degrees C) flue gas zone (FR and FS), ash deposits have higher sulfate content. While in high temperature flue gas zone (WW and PS), ash deposits have higher Si/Al content and lower S content. The Na/S contents in FR (similar to 1000 degrees C) are much higher than in other deposits. The thermal equilibrium calculation results showed that a large amount of liquid Na2SO4 and CaSO4 will be generated when burning WCW coal. Co-firing WD and WCW coals can reduce the amount of sulfate (1/slag) formation and the co-firing ratio greatly influence the elimination effect. It can be speculated that not all the sulfates in the ash deposits are formed in flue gas. The sulfation of the Na-containing minerals condensed on the heating surfaces will promote the ash deposition.
What problem does this paper attempt to address?