Abstract:Zhundong coal, high-quality coal with large reserves in China, faces great challenges on its large-scale utilization in utility boilers due to the ash-related problems caused by high alkali and alkali earth metals (AAEMs). In this research, to simulate ash deposition behavior on heating surfaces in high temperature flue gas zone (panel superheater) and that in medium-temperature flue gas zone (superheater or reheater), deposition experiments were carried out during Zhundong coal combustion in a drop tube furnace (DTF) at the deposition temperature of 1200 degrees C and 900 degrees C. Meanwhile, water leaching, Na2CO3 additive and kaolin additive were employed to elucidate the formation mechanism of ash deposition and alleviate deposition and slagging. Results showed that leaching reduced the contents of troublesome elements such as AAEMs and S and increased the relative contents of Si and Al, thus alleviating ash deposition. Compared with raw coal, the deposition rate of leached coal decreased from 5.82 mg h(-1) cm(-2) to 0.88 mg h(-1) cm(-2) at the deposition temperature of 900 degrees C. The primary reason for the decreased deposition rate might be that the dominant minerals in leached coal ash were refractory SiO2, CaO and Ca2SiO4. The addition of Na2CO3 would aggravate the slagging and fouling on the deposition surface significantly. The gaseous Na2O decomposed from Na2CO3 reacted with SO2 and SiO2 in the flue gas to form low-melting Na2SO4 and Na2Si3O7, which were easy to cause severe slagging on the deposition surface. The inhibition effect of kaolin addition on the formation of deposition and slagging was similar to that of leaching. After the addition of kaolin, the dominant compounds of fly ash altering to high-melting minerals such as CaSiO3, CaSO4, Ca2MgSi2O7 and NaCaAlSi2O7, resulting in a lower deposition rate than raw coal. Besides, when deposition temperature increased from 900 degrees C to 1200 degrees C the slagging degree of deposition surfaces was aggravated, while the deposition rate of four fuels followed different change trends. Specifically, the deposition rate of raw coal and leached coal decreased, whereas that of the case with Na additive and kaolin additive presented an increasing trend. At last, the role of water leaching and additives on the formation of ash deposition during Zhundong coal combustion was clarified. (C) 2020 Energy Institute. Published by Elsevier Ltd. All rights reserved.

Mineral conversion and thermodynamic simulation of ash deposition during Zhundong coal combustion in boiler of thermal power plant

Mineral transformation during rapid heating and cooling of Zhundong coal ash

Ash Deposition of Zhundong Coal in a 350 MW Pulverized Coal Furnace: Influence of Sulfation

The morphological and mineralogical characteristics and thermal conductivity of ash deposits in a 220 MW CFBB firing Zhundong lignite

Mineral Distribution in Pulverized Blended Zhundong Coal and Its Influence on Ash Deposition Propensity in a Real Modern Boiler Situation

Ash Deposition and Inorganic Element Transformation During Zhundong Coal Combustion

Understanding the mechanism of ash deposition on boiler heating surface: The lattice Boltzmann and molecular dynamics simulations

Investigation of Ash Deposition Characteristics in Full-Scale Circulating Fluidized Bed Boiler Burning Zhundong Coal

Mineral Conversion of Coal-ash in Fusing Process and the Influence to Ash Fusion Point

The Ash Deposition Mechanism in Boilers Burning Zhundong Coal with High Contents of Sodium and Calcium: A Study from Ash Evaporating to Condensing

Investigation on Ash Deposition Characteristics During Zhundong Coal Combustion

THE EFFECT OF CALCIUM-BEARING MINERAL ON ASH MELTING BEHAVIOR DURING ZHUNDONG COAL COMBUSTION

Ash Deposition and Sodium Migration Behaviors During Combustion of Zhundong Coals in a Drop Tube Furnace

Understanding Ash Deposition for the Combustion of Zhundong Coal: Focusing on Different Additives Effects

Quantitative analysis of minerals of blended coal ash at high temperature and its influence on slagging

Effects of Ash Compositions in Zhundong Coal on Its Ash Fusion Behavior and Crystal Phase Transformation

Mechanisms Of Inorganic Element Transfer During Zhundong Coal Combustion In Drop Tube Furnace

The Mineralogy Analysis Of Ash Deposition In Refractory Zones In A W-Flame Boiler

Influence of kaolin on sodium retention and ash fusion characteristic during combustion of Zhundong coal

Effects of Leaching and Additives on the Formation of Deposits on the Heating Surface During High-Na/ca Zhundong Coal Combustion

In Situ Diagnostics on the Dynamic Processes of Ash Deposit Formation, Shedding, and Heat Transfer in a Self-Sustained Down-Fired Furnace