Abstract:The Si–C–H thin films were deposited at 300°C by plasma enhanced chemical vapor deposition (PECVD) and around 600°C by pyrolysis CVD, in which C2H4 and SiH4 were used as the resource gases and hydrogen as the carrying vehicle. The formation of micro-crystals in the Si–C–H films was investigated by TEM, IR spectroscopy and electrical resistivity measurements. The results show that many silicon nano-crystalline particles are embedded and distributed uniformly in the amorphous matrix of the Si–C–H thin film. A higher content of C2H4 results in a lower crystallinity of the film deposited both by PECVD and pyrolysis CVD. The crystal grows more easily in the film deposited with C2H4–SiH4 at high temperature around 600°C by pyrolysis CVD than that deposited at 300°C by PECVD. The resistivity of the film by pyrolysis CVD at high deposition temperature is about five orders of magnitude lower than that by PECVD at low deposition temperature. The SiC crystalline phase trends to form quite possibly in the Si–C–H thin film deposited at 630°C by pyrolysis CVD. The expressions of the crystallinity and resistivity as functions of the content of C2H4 are theoretically deduced. The theoretical curves are showed to be very coincident with the experimental results in the Si–C–H thin film. The crystallinity of the film rests mainly with the nucleation rate of silicon phase that is dependent on the content of C2H4 in deposition source gases. The resistivity behavior of Si–C–H thin film matches with the parallel model of the two phase events, where the contribution of crystalline phase is appropriate to the contact probability among the silicon crystals and compatible with homogeneous distribution of the particles embedded in matrix.

Growth of Crystalline SiC Film Free of Cavities by Heating PS/silica Sol-Gel Coatings on Si (111) Substrate

EPITAXIAL GROWTH OF (0001)ORIENTED 6H-Sic FILMS ON Si(111) SUBSTRATE BY ORGANIC SOL-GEL FILM ANNEALING

Growth of Single Crystalline 4H-Sic Film by Pyrogenation of PS/OCS/Si(111) Nappe in Low-pressure Ambient Ar and Mechanism of Suppressing Interfacial Dislocations

Growth and Chemical Thermodynamics Analysis of SiC Film on Si Substrate by Heating Polystyrene/Silica Bilayer Method

Growth and Mechanical Properties of Amorphous and Nanostructured SiC films

Growth of Si-C-H film by RF plasma enhanced chemical vapor deposition

Growth Kinetics of Silicon Carbide Film Prepared by Heating Polystyrene/Si(111)

Influence of the partial pressure of ethene on the crystallinity of 3C-SiC films grown on Si(111) by chemical vapor deposition

Characteristics of laser-densified and conventionally heat treated sol–gel derived silica–titania films

The Preparation of Single-Crystal 4H-Sic Film by Pulsed XeCl Laser Deposition

Preparation of SiC from Water Soluble Phenol-formaldehyde Resin

Growth of Β-Sic Film by Pyrolysis of Polyimide Langmuir–Blodgett Films on Silicon

Effects of Carbon Additions on Crystallinity and Resistivity in Si–C–H Thin Films Deposited by CVDs

The Growth of Si on Sic Complex Substrate by Cvd

Synthesis of nanostructured SiC films by plasma enhanced chemical vapor deposition with hydrogen diluted hexalmethyldisiloxane as precursor

Preparation of Si–C–H thin films embedded with high oriented (100) polycrystalline silicon

Growth of SiC Thin Films on (100) and (111) Silicon by Pulsed Laser Deposition Combined with a Vacuum Annealing Process

Nucleation and Growth of Polycrystalline SiC

Crystallization of Ion-Beam-synthesized SiC Layer by Thermal Annealing

Influences of Surface Pretreatment on SiC Films Grown by Atmospheric Pressure Chemical Vapor Deposition Process on SiO2/Si Structures

Growth of 3C–SiC on 150-mm Si(100) substrates by alternating supply epitaxy at 1000°C