Abstract:Optimizing thermal anneals of Si-implanted β-Ga2O3 is critical for low resistance contacts and selective area doping. We report the impact of annealing ambient, temperature, and time on the activation of room temperature ion-implanted Si in β-Ga2O3 at concentrations from 5 × 1018 to 1 × 1020 cm−3, demonstrating full activation (>80% activation, mobilities >70 cm2/V s) with contact resistances below 0.29 Ω mm. Homoepitaxial β-Ga2O3 films, grown by plasma-assisted molecular beam epitaxy on Fe-doped (010) substrates, were implanted at multiple energies to yield 100 nm box profiles of 5 × 1018, 5 × 1019, and 1 × 1020 cm−3. Anneals were performed in an ultra-high vacuum-compatible quartz furnace at 1 bar with well-controlled gas compositions. To maintain β-Ga2O3 stability, pO2 must be greater than 10−9 bar. Anneals up to pO2 = 1 bar achieve full activation at 5 × 1018 cm−3, while 5 × 1019 cm−3 must be annealed with pO2 ≤ 10−4 bar, and 1 × 1020 cm−3 requires pO2 < 10−6 bar. Water vapor prevents activation and must be maintained below 10−8 bar. Activation is achieved for anneal temperatures as low as 850 °C with mobility increasing with anneal temperatures up to 1050 °C, though Si diffusion has been reported above 950 °C. At 950 °C, activation is maximized between 5 and 20 min with longer times resulting in decreased carrier activation (over-annealing). This over-annealing is significant for concentrations above 5 × 1019 cm−3 and occurs rapidly at 1 × 1020 cm−3. Rutherford backscattering spectrometry (channeling) suggests that damage recovery is seeded from remnant aligned β-Ga2O3 that remains after implantation; this conclusion is also supported by scanning transmission electron microscopy showing retention of the β-phase with inclusions that resemble the γ-phase.

Comprehensive study of Ga activation in Si, SiGe and Ge with 5 × 10<sup>−10</sup> Ω·cm<sup>2</sup> contact resistivity achieved on Ga doped Ge using nanosecond laser activation

Comprehensive Study Of Ga Activation In Si, Sige And Ge With 5 X 10(-10) Omega.Cm(2) Contact Resistivity Achieved On Ga Doped Ge Using Nanosecond Laser Activation

Dopant Activation In Poly-Si1-Xgex At Low Temperature

Dopant Activation in Poly-SI/sub1-x/Ge/subx/ at Low Temperature

Dopant redistribution and activation in Ga ion-implanted high Ge content SiGe by explosive crystallization during UV nanosecond pulsed laser annealing

Germanium Doping of Si Substrates for Improved Device Characteristics and Yield

Evaluation of the chemical states and electrical activation of ultra-highly B-doped Si 1-x Ge x by ion implantation and subsequent nanosecond laser annealing

Thermal activation of low-density Ga implanted in Ge

Band gap narrowing and doping level of heavily doped Germanium nanocrystals deduced from photoconductivity studies

Fabrication of Ge:Ga Hyperdoped Materials and Devices Using CMOS-Compatible Ga and Ge Hydride Chemistries

Direct-Bandgap Electroluminescence from Germanium with Subband Engineering Utilizing a Metal-Oxide-Semiconductor Structure

Silicon Ion Implant Activation in β-(Al0.2Ga0.8)2O3

Low-Mg out-diffusion of a normally off p-GaN gate high-electron-mobility transistor by using the laser activation technique

Study on the p-type ohmic contact in GaAs-based laser diode

High Performance Ge Ultra-Shallow Junctions Fabricated by A Novel Formation Technique Featuring Spin-On Dopant and Laser Annealing for Sub-10 Nm Technology Applications

Low temperature deactivation of Ge heavily n-type doped by ion implantation and laser thermal annealing

Capacitively Coupled Plasma-Stimulated Room-Temperature Mg and Mn Doping and Electrical Activation in GaAs

Si-implantation for Low Ohmic Contact Resistances in RF GaN HEMTs

Silicon implantation and annealing in β -Ga2O3: Role of ambient, temperature, and time

Continuous wave CO2 laser induced diffusion of Zn into GaAs using a solid state diffusion source

Activation of Mg Impurities in Epitaxial P-Gan with Rapid Thermal Annealing Assisted Supercritical Fluid Treatment