Abstract:Synthetic tetrahedrite (Cu12Sb4S13) is considered a promising p-type thermoelectric material owing to its intrinsically low thermal conductivity, relative nontoxicity, and presence of light elements Cu and S. Since Cu12Sb4S13 has a high carrier (hole) concentration, its power factor can be optimized by decreasing the carrier concentration via doping. In this study, Zn doping is performed to optimize the power factor by reducing the carrier concentration, and Bi doping is performed to reduce the lattice thermal conductivity through additional phonon scattering by atomic mass fluctuation and lattice distortion. Cu12−xZnxSb4−ySbyS13 tetrahedrites (0.1 ≤ x ≤ 0.4 and 0.1 ≤ y ≤ 0.4) were prepared using mechanical alloying and hot pressing, and the effects of double doping of Zn and Bi on the charge transport and thermoelectric properties were examined. X-ray diffraction analysis revealed the successful formation of the tetrahedrite phase, but a small amount of skinnerite phase (Cu3SbS3) was produced with an increase in the Bi content. The lattice constant increased with an increase in Zn and Bi doping contents, as the ionic radii of Zn and Bi were larger than those of Cu and Sb, respectively. With an increase in the Zn content and a decrease in the Bi content, the carrier concentration decreased. Consequently, the electrical conductivity decreased, whereas the Seebeck coefficient increased. The decline in the electrical conductivity with Zn doping dominated the increase in the Seebeck coefficient, which in turn reduced the power factor. However, the power factor did not change significantly with a change in the Bi content. The lattice thermal conductivity was close to the theoretical minimum value in tetrahedrite upon substituting with Zn and Bi, and thus, the thermal conductivities of all the specimens were less than 0.94 Wm−1 K−1 at temperatures ranging from 323 to 723 K. Consequently, the dimensionless figure of merit, ZT = 0.77, was obtained for Cu11.9Zn0.1Sb3.9Bi0.1S13 at 723 K, which was attributed to a relatively high power factor (0.83 mWm−1 K−2) and low thermal conductivity (0.76 Wm−1 K−1).

Thermoelectric Properties of Cu2S Doped with P, As, Sb and Bi—Theoretical and Experimental Studies

Doping-mediated stabilization of copper vacancies to promote thermoelectric properties of Cu2−xS

Structural features and thermoelectric performance of Sb- and Bi-doped Cu2SnSe3 compounds

Thermoelectric Properties of Doped-Cu3SbSe4 Compounds: A First-Principles Insight

Enhancement of low-temperature thermoelectric performance via Pb doping in Cu3SbSe4

Effect of Pb Doping on the Thermoelectric Performance of Eco-Friendly Cu 3 SbS 4

Pseudopolymorphic Phase Engineering for Improved Thermoelectric Performance in Copper Sulfides

Enhancing thermoelectric performance of Cu1.8S by Sb/Sn co-doping and incorporating multiscale defects to scatter heat-carrying phonons

Investigation of structural, morphological, optical and electronic properties of Cu-doped PbS thin films: a comparative experimental and theoretical study

Cu2−xS and Cu2−xSe Alloys: Investigating the Influence of Ag, Zn, and Ni Doping on Structure and Transport Behavior

Thermoelectric Performance Enhancement of Cu2S by Se Doping Leading to a Simultaneous Power Factor Increase and Thermal Conductivity Reduction

Enhanced thermoelectric performance of Bi<sub>2-x</sub>Cu<sub>x</sub>S<sub>3</sub> by hydrothermal synthesis and spark plasma sintering

Enhanced Thermoelectric Properties of Cu3SbSe4 Compounds by Isovalent Bismuth Doping

Electronic Transport and Thermoelectric Properties of Cu12-xZnxSb4S13 Tetrahedrites Prepared by Mechanical Alloying and Hot Pressing

Unlocking the Potential of Cu3SbSe3: Ultralow Thermal Conductivity and Enhanced Thermoelectric Performance

A combined experimental and modelling approach for the evaluation of the thermoelectric properties of Ag-doped SnS

Simultaneous Enhancement in the Power Factor and Thermoelectric Performance of Copper Sulfide by In2s3 Doping

Effects of bismuth doping on the thermoelectric properties of Cu 3SbSe4 at moderate temperatures

Effects of Sb Deviation from Its Stoichiometric Ratio on the Micro- and Electronic Structures and Thermoelectric Properties of Cu12Sb4S13.

Enhanced thermoelectric performance of Bi2-xCuxS3 by hydrothermal synthesis and spark plasma sintering

Effects of Zn/Bi Double Doping on the Charge Transport and Thermoelectric Properties of Tetrahedrites Cu 12− X Zn X Sb 4− Y Bi Y S 13