Abstract:The effect of gel preparation and heat treatment on the structural and optical properties of SiO2-ZnO materials prepared by the sol–gel method was investigated. Zinc acetate dehydrate, TEOS (tetraethylortosilicate), ethanol, distillated water and HCl were used as a starting material, solvent and catalyst, respectively. Four powders (G1–G4) were prepared in different ways from the starting materials mentioned above. The method of adding Zn precursors during the synthesis differed from one another. For the G1 synthesis, only Zn acetate powder was employed; for the G2 synthesis, Zn acetate was dissolved in distilled water; and for the G3 synthesis, Zn acetate was dissolved in ethanol. When synthesizing G4, TEOS was added last, after Zn acetate had been combined with water and ethanol. The SiO2-ZnO materials were dried at 200 °C and then heat-treated at 700 °C and 900 °C. All samples were investigated by X-ray diffraction and infrared spectroscopy in order to investigate their structure. SEM measurements were performed to investigate the morphology of materials. Optical properties were influenced by gel preparation and heat treatments. A reflectance of over 60% was obtained for G3 and G4 powders, while for G1 and G2, the reflectance was below 30%. In conclusion, synthesis steps and heat treatment can control the structure and properties of the powders.

Study On Preparation Of Sio2 Optical Fiber Preform By Sg Method

Process Research of Amorphous SiO2 for Optical Fiber Preform by Sol-Gel

<sub></sub>Effect of Anti-Cracking Agent on Cracking Property of SiO<sub>2</sub> Optical Fiber Preform by Sol-Gel Method

Effect of anti-cracking agent on cracking property of SiO2 optical fiber preform by sol-gel method

Effect on SiO2 gel for optical fiber preform by hydrochloric acid and formamide in sol-gel method

Preparation and characterization of ZnO-B2O3-SO2 by sol-gel method

New fabrication technology of SiO2 optical fiber preform

Preparation and Characterization of ZnO-B2O3-SiO2 by Sol-Gel Method

Preparation and Characterization of Silica Fibers Via Sol-gel Method

STUDY ON THE PREPARATION TECHNIQUE OF SiO2 AEROGELS/FIBER COMPOSITES

CHARACTERIZATION OF SiO2 AEROGELS/FIBER COMPOSITES PREPARED BY THE SOL-GEL METHODS

The Study of the Silicon Dioxide Anti-Reflection Film Prepared by the Sol-Gel Method

Preparation of SiO2 aerogels with sol-gel method and the study of their properties

Sol-Gel Preparation and Optical Nonlinearity of CdS Microcrystallite-Doped SiO2-TiO2thin Films

Preparation of SiC from Water Soluble Phenol-formaldehyde Resin

Preparation of SiO2-TiO2 Planar Optical Waveguide with Sol-Gel Method

Preparation of Mullite Fibers by Sol-Gel Process and Study of Their Morphology

Preparation and Crystallization of Si-Al Gel

The Influence of Gel Preparation and Thermal Treatment on the Optical Properties of SiO2-ZnO Powders Obtained by Sol–Gel Method

Preparation of Silica Membrane by So-l gel Method and Its Performances

Preparation and Characterizations of TiO2/Organically Modified Silane Composite Materials Produced by the Sol-Gel Method