Abstract:The effect of gel preparation and heat treatment on the structural and optical properties of SiO2-ZnO materials prepared by the sol–gel method was investigated. Zinc acetate dehydrate, TEOS (tetraethylortosilicate), ethanol, distillated water and HCl were used as a starting material, solvent and catalyst, respectively. Four powders (G1–G4) were prepared in different ways from the starting materials mentioned above. The method of adding Zn precursors during the synthesis differed from one another. For the G1 synthesis, only Zn acetate powder was employed; for the G2 synthesis, Zn acetate was dissolved in distilled water; and for the G3 synthesis, Zn acetate was dissolved in ethanol. When synthesizing G4, TEOS was added last, after Zn acetate had been combined with water and ethanol. The SiO2-ZnO materials were dried at 200 °C and then heat-treated at 700 °C and 900 °C. All samples were investigated by X-ray diffraction and infrared spectroscopy in order to investigate their structure. SEM measurements were performed to investigate the morphology of materials. Optical properties were influenced by gel preparation and heat treatments. A reflectance of over 60% was obtained for G3 and G4 powders, while for G1 and G2, the reflectance was below 30%. In conclusion, synthesis steps and heat treatment can control the structure and properties of the powders.

Preparation and Characterization of ZnO-B2O3-SiO2 by Sol-Gel Method

Preparation and characterization of ZnO-B2O3-SO2 by sol-gel method

Sol–gel preparation of Ge nanocrystals embedded in SiO2 glasses

Photoluminescence Property of ZnO–SiO2composites Synthesized by Sol–gel Method

A General Propylene Epoxide-assisted Sol-Gel Route for the Synthesis of ZrO2-SnO2 Composite Sols

Preparation of Zirconia Powders by Sol-gel Process

Preparation and Characterization of Mg-doped ZnO Thin Films by Sol–gel Method

Sol-Gel Preparation of Ag/ZnO Films and Their Electrical and Optical Properties

Formation and transformation of ZnTiO3 prepared by sol–gel process

Preparation and optical characteristics of ZnO films by chelating sol-gel method

Preparation and Phase Formation Mechanism of CaSiO3 Doped with Mg/CaSiO3 by Sol-Gel Method

THERMAL DECOMPOSITION AND CRYSTALLIZATION PROCESS OF ZnO:Al THIN FILMS VIA SOL-GEL ROUTE

A Study of Formation and Photoluminescence Properties of ZnO Quantum Dot Doped Zinc-Alumino-silicate Glass Ceramic

Preparation and Properties of CaTiO_3:Zn Nanoparticles Based on Sol-Gel Method

Preparation and Crystallization of Si-Al Gel

Fabrication of SiO2 and SiO2-ZrO2 gel glasses by non-hydrolytic sol-gel process

The Influence of Gel Preparation and Thermal Treatment on the Optical Properties of SiO2-ZnO Powders Obtained by Sol–Gel Method

Characterization of ZnO Thin Film Preparation by Sol-Gel Spinning-Coating

Phase Characterization and Dielectric Properties of Zn2SiO4 Ceramics Derived from a Sol-Gel Process

Mgo-Al2o3-Sio2 Glass-Ceramic Prepared by Sol-Gel Method

Preparation of Sodium Borosilicate Transparent Bulk Gel