Abstract:Al-doped zinc oxide thin films are prepared on glass slides by sol-gel process at room temperature plus heat post-treatment.X-ray diffraction(XRD) and scanning electron microscope(SEM) are employed to analyze the composition,structure and morphology of the films.Ultraviolet-visible spectrophotometry is applied to measure trans-mittance properties of the films.Results show that the thin films obtained possess hexagonal wurtzite structure with highly preferred orientation along the(002) plane.Al~(3+) doping into ZnO films don't affect the basic ZnO crystal form of the films.It is found that the Al~(3+) substitutes the Zn's place in ZnO lattice,i.e.substitute doping.After heat treatment, Al~(3+)-doped ZnO grains show hexagonal needle-shaped(or pillar shape) crystal morphology.The higher the heat treatment temperature is,the better the transmittance of the films is.For the film after heating at 600℃,the transmit-tance of the film increases first and decreases afterwards with the increase of Al~(3+) doping concentration,the best transmittance presents at 2%of Al~(3+) doping concentration.The effect of lattice deformation arising from the dopants,which leads to the decrease of the transmittance of the film,can not be ignored at higher Al~(3+) doping concentration anymore.

Characterization of ZnO Thin Film Preparation by Sol-Gel Spinning-Coating

Effect of Solution Concentrations on Crystal Structure, Surface Topographies and Photoluminescence Properties of ZnO Thin Films

Preparation and Characterization of Na-doped ZnO Thin Films by Sol–gel Method

Preparation of ZnO thin film by sol-gel technique and its properties

Surface Topography and Optical Properties of Al-doped ZnO Thin Films by Sol-gel Process

Preparation and Characterization of Mg-doped ZnO Thin Films by Sol–gel Method

Investigation on the Structural and Optical Properties of ZnO Thin Films Prepared by Sol-Gel Method

Microstructue and Optical Properties of Mg-doped ZnO Thin Films Prepared by Sol-gel Method

Influences of Processing Parameters on the Properties of Zno Thin Films Prepared by Sol-Gel Spin-Coating

Preparation and Microstructure of ZnO Thin Films by SOL-GEL Process

Structural and Optical Properties of ZnO Thin Films Prepared by Sol–gel Method with Different Thickness

Preparation and optical characteristics of ZnO films by chelating sol-gel method

Characterization of MgxZn1−xO Thin Films Prepared by Sol–gel Dip Coating

Preparation and Properties of Sol-Gel ZnO Thin Films

Preparation and Properties of ZnO Thin Films Deposited by Sol-Gel Technique

Structure and luminescent properties of ZnO thin films

Sol-gel Fabrication and Characterization of Al-doped ZnO Thin Films

Electrical and Optical Properties of Zinc Oxide Films Prepared by Pyrolysis of Zinc Acetate

Structure and Photoluminescence Property of Znwo4 Films Prepared by Sol-Gel Processing

Preparation and the Photoelectric Properties of ZnO-SiO2 Films with a Sol–Gel Method Combined with Spin-Coating

Pretreating Temperature Controls on Structural, Morphological and Optical Properties of Sol–gel ZnO Thin Films