Abstract:We report synthesis of hydrogenated nanocrystalline silicon (nc-Si:H) thin films by using conventional plasma enhanced chemical vapor deposition (PE-CVD) system from gas mixture of pure silane (SiH4) and hydrogen (H2). We investigated the effect of RF power on structural, optical and electrical properties using various characterization techniques including Raman spectroscopy, FTIR spectroscopy, UV–visible spectroscopy etc. Low angle XRD and Raman spectroscopy analysis revealed that the RF power in PE-CVD is a critical process parameter to induce nanocrystallization in Si:H films. The FTIR spectroscopy analysis results indicate that with increase in RF power the predominant hydrogen bonding in films shifts from Si–H to Si–H2 and (Si–H2)n bonded species bonded species. However, the bonded hydrogen content didn’t show particular trend with change in RF power. The UV–visible spectroscopy analysis shows that the band tail width (E04–ETauc) with increase in RF power. The defect density and Urbach energy also increases with increase in RF power. The highest dark conductivity (and lowest charge carrier activation energy) was obtained for the film deposited at RF power of 125 W indicating that 125 W is optimized RF power of our PE-CVD unit. At this optimized RF power nc-Si:H films with crystallite size ~3.7 nm having good degree of crystallinity (~86.7 %) and high band gap (ETauc ~ 2.01 eV and E04 ~ 2.58 eV) were obtained with a low hydrogen content (6.2 at.%) at moderately high deposition rate (0.24 nm/s).

Research On Silane Depletion Status During The Deposition Of Silicon Thin Films By High-Pressure Pecvd

Deposition of Dense SiO2 Thin Films for Electrical Insulation Applications by Microwave ECR Plasma Source Enhanced RF Reactive Magnetron Sputtering

Preparation and Photoluminescence of Nanocrystalline Si-Rich Silicon Oxide Films by Pecvd

Analysis of Silicon Thin Film Prepared at Different Hydrogen Dilutions by VHF-PECVD

The Effect of Relatively Low Hydrogen Dilution on the Properties of Carbon-Rich Hydrogenated Amorphous Silicon Carbide Films

Key Issues for High-Efficiency Silicon Thin Film Solar Cells Prepared by RF-PECVD under High-Pressure-depletion Conditions

Effects of Discharge Power on Silicon-based Films Fabricated by VHF-PECVD

Effect of Silane Concentration on Intrinsic Microcrystalline Silicon

The Influence of Radio Frequency Power on the Characteristics of Carbon-Rich Hydrogenated Amorphous Silicon Carbide Films

THE OES IN DEPOSITING MICROCRYSTALLINE SILICON MATERIAL BY RF-PECVD

Transport properties of µc-Si:H films prepared by very high hydrogen-diluted silane plasma

Cold Deposition of Large-Area Amorphous Hydrogenated Silicon Films by Dielectric Barrier Discharge Chemical Vapor Deposition

High Rate Deposition of Stable Hydrogenated Amorphous Silicon in Transition from Amorphous to Microcrystalline Silicon

Very High Hydrogen Dilution Induced Novel Phenomena of Electronic Transport Properties in Hydrogenated Microcrystalline Silicon-Germanium Thin Films Prepared by Plasma Enhanced Chemical Vapor Deposition Method

PROPERTIES OF PECVD SiNx FILM FOR SOLAR CELLS

Structure and Properties of Hydrogenated Amorphous Silicon Carbide Thin Films Deposited by Pecvd

Research on the optimum hydrogenated silicon thin films for application in solar cells

Deposition and Characterization of High-Efficiency Silicon Thin-Film Solar Cells by HF-PECVD and OES Technology

Transport Properties of Μc-Si:H Films Prepared by Very High Hydrogen-Diluted Silane Plasma

Microstructure Characterization of Microcrystalline Silicon Thin Films Deposited by Very High Frequency Plasma-Enhanced Chemical Vapor Deposition by Spectroscopic Ellipsometry

Influence of RF power on structural optical and electrical properties of hydrogenated nano-crystalline silicon (nc-Si:H) thin films deposited by PE-CVD