Abstract:In this paper, the processing parameters of growing GaN epilayer by hydride vapor phase epitaxy are optimized The influences of the low-temperature (LT) nucleation layer growth time, WM precursor ratio and the growth temperature on GaN layer are investigated by the high-resolution X-ray diffraction (HRXRD) signature for the asymmetric and symmetric reflections. The investigation finds that the LT-nucleation layer not only supplies the nucleation centers having good crystal quality, but also promotes the lateral growth of the sequent high temperature (HT) growth. The optimal LT nucleation layer growth time, WEI precursor ratio and the growth temperature can effectively enhance lateral growth to reduce the crystal defects and are favorable to converting the growth mechanism from threedimension to two-dimension in HT growth. The structural and optoelectronic properties of the as-grown GaN layer with a thickness of 15 um at the optimal parameters are studied by scanning electron microcopy, atomic force microscopy (AFM), HRXRD, Raman spectra, and photoluminescence (PL) measurements. X-ray rocking curves show that the full widths at half maximum of (002) and (102) are 317 and 343 arcsec, respectively. The surface roughness (rms: root mean square) is 0.334 nm detected using AFM. These characteristics show that the sample has good lattice quality and smooth surface morphology. In PL spectrum, the near band edge emission is dominated by emission from excitons bound to neutral donors (D X) near 3.478 eV with 11 meV blue-shift and the yellow band emission is very weak. The results indicate that the GaN layer has good crystal quality and excellent optoelectronic properties, but a little biaxial in-plane compressive strain also exists in it due to the lattice and thermal mismatch.

Effect of Additional HCl and Substrate Nitridation on GaN Films Grown by HVPE

Effect of Additional HCl on the Surface Morphology of High Quality GaN on Sapphire by HVPE

Effect of Additional HCl Flow on the Surface Morphology of HVPE GaN on Sapphire

The impact of initial growth and substrate nitridation on thick GaN growth on sapphire by hydride vapor phase epitaxy

Effect of Additional Hcl Flow on the Surface Morphology of Gan Grown on Sapphire by Hvpe

The Effect of Gan Single Crystal Substrate Characteristics on Homo-Epitaxial Gan Films

New Design of Nozzle Structures and Its Effect on the Surface and Crystal Qualities of Thick GaN Using a Horizontal HVPE Reactor

Modulation Effects of Hydrogen on Structure and Photoluminescence of GaN Nanowires Prepared by Plasma-Enhanced Chemical Vapor Deposition

Hydrogen induced changes on hydride vapor phase epitaxy of GaN growth

Optimization of the Parameters for Growth High-Qulity Gan Film by Hydride Vapor Phase Epitaxy

Effects of Growth Temperature Modulated by HCl Flow Rate on the Surface and Crystal Qualities of Thick GaN by HVPE

Hydride vapor phase epitaxial growth of thick GaN layers with in-situ optical monitoring

Properties of GaN film grown by hydride vapor phase epitaxy

Growth of GaN Quasi‐substrates by Hydride Vapor Phase Epitaxy

Influence of Ga Concentration in Si Substrates on the Quality of GaN Films

The Effects of Sapphire Nitridation on GaN Growth by Metalorganic Chemical Vapour Deposition

Effects of N_2 Carrier Gas Flow and System Temperature on the Quality of GaN Film

Growth of GaN Film on Graphene by HVPE

The Influence of V/III Ratio on GaN Grown on Patterned Sapphire Substrate with Low Temperature AlN Buffer Layer by Hydride Vapor Phase Epitaxy

Nitridation Effect of the Α-Al2o3 Substrates on the Quality of the GaN Films Grown by Pulsed Laser Deposition

The Nature and Impact of ZnO Buffer Layers on the Initial Stages of the Hydride Vapor Phase Epitaxy of GAN