Abstract:In this paper, the processing parameters of growing GaN epilayer by hydride vapor phase epitaxy are optimized The influences of the low-temperature (LT) nucleation layer growth time, WM precursor ratio and the growth temperature on GaN layer are investigated by the high-resolution X-ray diffraction (HRXRD) signature for the asymmetric and symmetric reflections. The investigation finds that the LT-nucleation layer not only supplies the nucleation centers having good crystal quality, but also promotes the lateral growth of the sequent high temperature (HT) growth. The optimal LT nucleation layer growth time, WEI precursor ratio and the growth temperature can effectively enhance lateral growth to reduce the crystal defects and are favorable to converting the growth mechanism from threedimension to two-dimension in HT growth. The structural and optoelectronic properties of the as-grown GaN layer with a thickness of 15 um at the optimal parameters are studied by scanning electron microcopy, atomic force microscopy (AFM), HRXRD, Raman spectra, and photoluminescence (PL) measurements. X-ray rocking curves show that the full widths at half maximum of (002) and (102) are 317 and 343 arcsec, respectively. The surface roughness (rms: root mean square) is 0.334 nm detected using AFM. These characteristics show that the sample has good lattice quality and smooth surface morphology. In PL spectrum, the near band edge emission is dominated by emission from excitons bound to neutral donors (D X) near 3.478 eV with 11 meV blue-shift and the yellow band emission is very weak. The results indicate that the GaN layer has good crystal quality and excellent optoelectronic properties, but a little biaxial in-plane compressive strain also exists in it due to the lattice and thermal mismatch.

The Nature and Impact of ZnO Buffer Layers on the Initial Stages of the Hydride Vapor Phase Epitaxy of GAN

Role of Interfacial Compound Formation Associated with the Use of Zno Buffers Layers in the Hydride Vapor Phase Epitaxy of Gan

Hydride vapor phase epitaxy growth of GaN on sapphire with ZnO buffer layers

Lateral and Vertical Growth Study in the Initial Stages of GaN Growth on Sapphire with ZnO Buffer Layers by Hydride Vapor Phase Epitaxy

The impact of initial growth and substrate nitridation on thick GaN growth on sapphire by hydride vapor phase epitaxy

Non-polar A-Plane ZnO Films Grown on R-Al2o3 Substrates Using GaN Buffer Layers

Surface morphology of ZnO buffer layer and its effects on the growth of GaN films on Si substrates by magnetron sputtering

Influence of Sputtered AlN Buffer on GaN Epilayer Grown by MOCVD

Hydrogen induced changes on hydride vapor phase epitaxy of GaN growth

The Effect of Gan Single Crystal Substrate Characteristics on Homo-Epitaxial Gan Films

The Growth of High-Quality and Self-Separation GaN Thick-Films by Hydride Vapor Phase Epitaxy

Optimization of the Parameters for Growth High-Qulity Gan Film by Hydride Vapor Phase Epitaxy

Hydride Vapor Phase Epitaxy of GaN on Silicon Covered by Nanostructures

Effects of the sputtering time of ZnO buffer layer on the quality of GaN thin films

Effect of Additional HCl on the Surface Morphology of High Quality GaN on Sapphire by HVPE

The Influence of V/III Ratio on GaN Grown on Patterned Sapphire Substrate with Low Temperature AlN Buffer Layer by Hydride Vapor Phase Epitaxy

Growth of GaN Quasi‐substrates by Hydride Vapor Phase Epitaxy

2 In. Free-standing GaN Grown by HVPE with Sputtered AlN Buffer on GaAs Substrate

Effects of Buffer Layer on Structural Properties of Nonpolar (112¯0)-Plane GaN Film

Synthesis of ZnAl 2 O 4 /Α-Al 2 O 3 Complex Substrates and Growth of GaN Films

Effect of Growth and Annealing on ZnO Buffer by MOCVD