Abstract:The deposition and crystallization of amorphous GaN buffer layers on Si(111) is firstly investigated by using an atomic force microscope (AFM), X-ray diffraction (XRD) and a high-resolution transmission electron microscope (HRTEM). The amorphous GaN layers were deposited by MOCVD at 300°C. The islanding process by annealing at higher temperatures has been revealed by AFM. It is found that the amorphous layers begin to be crystallized by solid-phase epitaxy at 500°C in MOCVD, and the full-developed islands formed at about 600°C. XRD data show that the GaN peak appeared only after an annealing at higher temperatures. Cross-sectional HRTEM micrographs of the buffer region of the samples with amorphous GaN buffer layers reveal that many domains exist in the GaN buffer layers and these domains misorientate each other with a small angle. The boundaries between domains locate near the bunched steps, and, the films on a terrace between steps have the same crystal orientation. The amorphous buffer layer deposited at 300°C and the buffer layer directly deposited at 550°C are used in the growth of GaN epilayers, respectively. The XRD results and photoluminescence at room temperature of such GaN epilayers show that using the amorphous GaN buffer layer lead to monocrystalline and a narrower full-width at half-maximum (FWHM) of near band emission (16nm) than using the buffer layer directly deposited at 550°C (FWHM of 21nm). These results indicate that the quality of GaN epilayer on Si(111) can be improved by using the amorphous GaN buffer layer.

Surface morphology of ZnO buffer layer and its effects on the growth of GaN films on Si substrates by magnetron sputtering

Effects of the sputtering time of ZnO buffer layer on the quality of GaN thin films

Epitaxial Growth Of Zno On Gan/Sapphire Substrate By Radio-Frequency Magnetron Sputtering

Non-polar A-Plane ZnO Films Grown on R-Al2o3 Substrates Using GaN Buffer Layers

Surface Morphology of AlN Buffer Layer and Its Effect on GaN Growth by Metalorganic Chemical Vapor Deposition

A Study on a Two-Step Technique of Growing Ga2O3/ZnO Films Ammoniated at Different Temperatures

Microstructural and Compositional Characteristics of GaN Films Grown on a ZnO-buffered Si (111) Wafer.

Initial Study on the Structure and Optical Properties of ZnO Film on Si(111) Substrate with a SiC Buffer Layer

Crystal characterization of zinc oxide thin film

Prepare of ZnAl2O4/-Al2O3 Complex Substrates and Growth of GaN Films

Effect of Growth and Annealing on ZnO Buffer by MOCVD

The Nature and Impact of ZnO Buffer Layers on the Initial Stages of the Hydride Vapor Phase Epitaxy of GAN

ZnO growth on Si with low-temperature CdO and ZnO buffer layers by molecular-beam epitaxy

Two-dimensional X-ray diffraction and transmission electron microscopy study on the effect of magnetron sputtering atmosphere on GaN/SiC interface and gallium nitride thin film crystal structure

Effect of a ZnO Buffer Layer on the Properties of Epitaxial ZnO:Ga Films Deposited on C-Sapphire Substrate

Role of Interfacial Compound Formation Associated with the Use of Zno Buffers Layers in the Hydride Vapor Phase Epitaxy of Gan

Synthesis of ZnAl 2 O 4 /Α-Al 2 O 3 Complex Substrates and Growth of GaN Films

Synthesis of ZnAl2O4/alpha-Al2O3 complex substrates and growth of GaN films

Structural and Optical Properties of ZnO Thin Films Grown by RF Reactive Magnetron Sputtering

Deposition and Crystallization of Amorphous Gan Buffer Layers on Si(111)Substrates

Surface Morphology and Composition Studies in InGaN/GaN Film Grown by MOCVD