Abstract:High-quality ZnO films were grown on Si(1 0 0) substrates with low-temperature (LT) ZnO buffer layers by an electron cyclotron resonance (ECR)-assisted molecular-beam epitaxy (MBE). In order to investigate the optimized buffer layer temperature, ZnO buffer layers of about 1.1 μm were grown at different growth temperatures of 350, 450 and 550 °C, followed by identical high-temperature (HT) ZnO films with the thickness of 0.7 μm at 550 °C. A ZnO buffer layer with a growth temperature of 450 °C (450 °C-buffer sample) was found to greatly enhance the crystalline quality of the top ZnO film compared to others. The root mean square (RMS) roughness (3.3 nm) of its surface is the smallest, compared to the 350 °C-buffer sample (6.7 nm), the 550 °C-buffer sample (7.4 nm), and the sample without a buffer layer (6.8 nm). X-ray diffraction (XRD), photoluminescence (PL) and Raman scattering measurements were carried out on these samples at room temperature (RT) in order to characterize the crystalline quality of ZnO films. The preferential c-axis orientations of (0 0 2) ZnO were observed in the XRD spectra. The full-width at half-maximum (FWHM) value of the 450 °C-buffer sample was the narrowest as 0.209°, which indicated that the ZnO film with a buffer layer grown at this temperature was better for the subsequent ZnO growth at elevated temperature of 550 °C. Consistent with these results, the 450 °C-buffer sample exhibits the highest intensity and the smallest FWHM (130 meV) of the ultraviolet (UV) emission at 375 nm in the PL spectrum. The ZnO characteristic peak at 438.6 cm−1 was found in Raman scattering spectra for all films with buffers, which is corresponding to the E2 mode.

Crystal characterization of zinc oxide thin film

The growth of nanoscale ZnO films by pulsed-spray evaporation chemical vapor deposition and their structural, electric and optical properties

Effect of Solution Concentrations on Crystal Structure, Surface Topographies and Photoluminescence Properties of ZnO Thin Films

Non-polar A-Plane ZnO Films Grown on R-Al2o3 Substrates Using GaN Buffer Layers

Growth of Cubic MgxZn1-xO Films and Characterization

Epitaxial Growth Of Zno On Gan/Sapphire Substrate By Radio-Frequency Magnetron Sputtering

Surface morphology of ZnO buffer layer and its effects on the growth of GaN films on Si substrates by magnetron sputtering

Comparison of Structural and Optical Properties of ZnO Films Grown on Different Substrates at Low Temperatures

Structural and Optical Characterizations of ZnO Films Grown by Reactive Electron Beam Evaporation

Characterizations of Cubic ZnMgO Films Grown on Si(111) at Low Substrate Temperature

Microstructural and Compositional Characteristics of GaN Films Grown on a ZnO-buffered Si (111) Wafer.

Microstructure Study of Zno Thin Films on Si Substrate Grown by Mocvd

The structure and optical characters of the ZnO film grown on GaAs/Al2O3 substrate

Growth of c-Axis Oriented Si-Based ZnO Films Using Al as Transitional Films and Fabrication of Its Schottky Diodes

Characterization of ZnO Thin Films Prepared on SIO2/Si Substrates

Effect of Growth and Annealing on ZnO Buffer by MOCVD

Structural, optical and electrical properties of ZnO thin films prepared by reactive deposition

ZnO Growth on Si with Low-Temperature ZnO Buffer Layers by ECR-assisted MBE

Fabrication and Characteristics of ZnO Thin Films with an Al/Si (100) Substrates

Studies on Crystal Structure of ZnO Films by the Mis-orientation

Structural Characteristics of ZnO Epilayer Grown on Si Substrates