Abstract:Being an important semiconductor material for high power applications, silicon carbide (SiC) faces the problems while used as a gate oxygen layer in traditional Si MOS devices. In view of this, an innovative approach was adopted in the present work to replace the conventional SiO2 with a high-k material (ZrO2) as the gate oxygen layer to investigate its effect on the electrical characteristics of the devices. In particular ZrO2 films were deposited on Si and SiC substrates by atomic layer deposition (ALD), and Al was used as the electrode. The atomic force microscopy (AFM) microregion scan revealed a highly flat surface with R-q < 1 nm after the ALD growth of ZrO2 layer. The sample surface analysis via x-ray photoelectron spectroscopy (XPS) suggested the presence of a small amount of ZrOx components. According to the electron energy loss spectrum (EELS), the band gap width (E-g) of this ALD ZrO2 dielectric was 5.45 eV, which met the requirements for high-quality 4H-SiC-related MOS devices. The electrical properties of the samples were then studied, and the maximum breakdown voltage of the Al/ZrO2/SiC/Al MOS structure was obtained to be 23 V, i.e., nearly twice that of the Si substrate. As for the oxide layer, the interface defect density (D-it) near the conduction band of the Al/ZrO2/SiC/Al MOS structure was only 10(12) eV(-1) cm(-2) orders of magnitude. The N-eff value (the movable charge) of the structure was also controlled at 10(12) cm(-2). Therefore, the overall performance of the ZrO2/SiC structure in terms of electrical properties exceeded that of the ZrO2/Si structure and previously reported counterparts. In this respect, the ZrO2/SiC MOS capacitor structure has great research potential.

Interfacial and Optical Properties of Zro(2)/Si by Reactive Magnetron Sputtering

Properties of amorphous SiO2 films prepared by reactive RF magnetron sputtering method

Microstructure and Optical Properties of ZnO Films Deposited by Radio-frequency Reactive Magnetron Sputtering

Optical Properties Study of Silicon Oxynitride Films Deposited by RF Magnetron Sputtering

Deposition of Dense SiO2 Thin Films for Electrical Insulation Applications by Microwave ECR Plasma Source Enhanced RF Reactive Magnetron Sputtering

The Effects of Oxygen Partial Pressure and Substrate Temperature on the Structural and Optical Properties of Zno Films

Interfacial Properties of High-K Dielectric Cazrox Films Deposited by Pulsed Laser Deposition

Study on the thermal stability and electrical properties of the high- k dielectrics (ZrO 2 ) x (SiO 2 ) 1− x

INTERFACIAL MICROSTRUCTURE OF HIGH-κ DIELECTRIC CaZrOx FILMS DEPOSITED BY PULSE LASER DEPOSITION IN LOW OXYGEN PRESSURE

Infrared And Raman Spectroscopic Studies Of Optically Transparent Zirconia (Zro2) Films Deposited By Plasma-Assisted Reactive Pulsed Laser Deposition

Structural, Optical and Electrical Properties of High-K ZrO2 Dielectrics on Si Prepared by Plasma Assisted Pulsed Laser Deposition

Structural, Electrical, and Optical Properties of ZnInO Alloy Thin Films

Dielectric Properties of SrZrO3 Thin Films Prepared by Pulsed Laser Deposition

Structure and Dielectric Properties of Ultra-Thin ZrO2 Films for High- K Gate Dielectric Application Prepared by Pulsed Laser Deposition

Structure and Dielectric Property of High-k ZrO2 Films Grown by Atomic Layer Deposition Using Tetrakis(Dimethylamido)Zirconium and Ozone

Electronic properties of ZrO<sub>2</sub> films fabricated via atomic layer deposition on 4H-SiC and Si substrates

Structure and electrical characterization of amorphous ErSiO films deposited by rf magnetron sputtering on Si (001)

Crystal Growth of Undoped ZnO Films on Si Substrates under Different Sputtering Conditions

Interfacial and microstructural properties of zirconium oxide thin films prepared directly on silicon

Structure and dielectric properties of Zr-Al-O thin films prepared by pulsed laser deposition

Phase Separation Enhanced Interfacial Reactions in Complex High-K Dielectric Films