Abstract:Silicon carbide (SiC), an important semiconductor material used in high-power devices, faces the problem of gate oxygen layer formation in traditional Si MOS devices. In view of this, an innovative approach was adopted in the present work to replace the conventional SiO 2 as the gate oxygen layer with a high-k material (ZrO 2 ) so as to investigate its effect on the electrical characteristics of the appliance. In particular ZrO 2 films were deposited on SiC and Si substrates by atomic layer deposition (ALD), and Al was used as the electrode. The atomic force microscopy (AFM) microregion scan revealed a highly flat surface with Rq<1 nm after the ALD growth of ZrO 2 layer. The sample surface analysis via X-ray photoelectron spectroscopy (XPS) suggested the presence of a small amount of ZrO x components. According to the electron energy loss spectrum (EELS), the band gap width (Eg) of this ALD ZrO 2 dielectric was 5.45 eV, which met the requirements for high-quality 4H-SiC-related MOS devices. The electrical properties of the samples were then studied, and the maximum breakdown electric field of the MOS capacitor structure on the SiC substrate was obtained to be more than 10 MV/cm, i.e., nearly twice that of the Si substrate. Based on capacitance-voltage (C-V) measurements, the interface defect density (Dit) near the conduction band of the MOS capacitive structure of the SiC substrate was only on the order of 10 12 eV -1 cm -2 . The movable charge Neffof the oxide layer was also controlled at 10 12 cm -2 . Therefore, the overall performance of the ZrO 2 /SiC structure in terms of electrical properties exceeds that of the ZrO 2 /Si structure and previously reported counterparts. Thus, the combination of the high-k material (ZrO 2 ) and SiC as the substrates in MOS capacitor structures is a very promising research direction.

Structure and Dielectric Properties of Ultra-Thin ZrO2 Films for High- K Gate Dielectric Application Prepared by Pulsed Laser Deposition

Preparation Of Low-K Nanoporous Sio2 Films By Plasma-Enhanced Chemical Vapor Deposition

Pulsed Laser Deposition of Zirconium Silicate Thin Films As Candidate Gate Dielectrics

Thermal Stability and Electrical Properties of Zr Silicate Films for High- K Gate-Dielectric Applications, As Prepared by Pulsed Laser Deposition

Structure and dielectric properties of Zr-Al-O thin films prepared by pulsed laser deposition

Pulsed Laser Deposited Zralon Films for High-K Gate Dielectric Applications

Fabrication and Characterization of Zr-Rich Zr-Aluminate Films for High-Kappa Gate Dielectric Applications

Structure and Dielectric Property of High-k ZrO2 Films Grown by Atomic Layer Deposition Using Tetrakis(Dimethylamido)Zirconium and Ozone

Dielectric Properties of SrZrO3 Thin Films Prepared by Pulsed Laser Deposition

Microstructure, optical and electrical properties of solution-derived peroxo-zirconium oxide gate dielectrics for CMOS application

Enhanced Dielectric Properties of ZrO2thin Films Prepared in Nitrogen Ambient by Pulsed Laser Deposition

Thermal stability and dielectric properties of ultrathin CaZrO x films prepared by pulsed laser deposition

Electronic properties of ZrO<sub>2</sub> films fabricated via atomic layer deposition on 4H-SiC and Si substrates

Structural, Optical and Electrical Properties of High-K ZrO2 Dielectrics on Si Prepared by Plasma Assisted Pulsed Laser Deposition

Study on the thermal stability and electrical properties of the high- k dielectrics (ZrO 2 ) x (SiO 2 ) 1− x

Electronic Properties of ZrO2 Films Fabricated via Atomic Layer Deposition on 4H-SiC and Si Substrates

Atomic Layer Deposition Deposited High Dielectric Constant (κ) ZrAlOx Gate Insulator Enabling High Performance ZnSnO Thin Film Transistors

Preparation And Characterization Of Sol-Gel Derived Cazro3 Dielectric Thin Films For High-K Applications

Interfacial Properties of High-K Dielectric Cazrox Films Deposited by Pulsed Laser Deposition

Optical and Electric Properties of ZrO2 Gate Dielectric Films

Microstructure and Electrical Properties of Al2O3–ZrO2 Composite Films for Gate Dielectric Applications