Abstract:The photovoltaic properties of the polycrystalline silicon depend on the crystallinity and the purity of the material. The thermal plasma process gives us an alternative method of silicon preparation since it is possible to produce an ultrahigh purity with simultaneously a passivation of crystalline defects and active impurities. We demonstrate the efficiency of the plasma purification process and particularly the influence of the atomic hydrogen in an argon thermal plasma on the photovoltaic properties of silicon. The results of the diffusion lengths measured by the photoelectrochemical method show that locally it rises up to 200 μm. We correlate these photovoltaic measurements with the properties of the crystal (defects and purity) by means of measurements by Fourier transform infrared spectroscopy (FTIR) at low temperature (6 K), four probes resistivity technique, scanning electronic microscopy, inductively coupled plasma (ICP), and neutronic activation analyses. We show that the increase of the purity explains the high me asured diffusion lengths. Nevertheless, the thermal conditions of the crystallization of the silicon, due to the specificity of the plasma, lead to defects such as dislocations for which density is particularly high (>10 6 dis/cm 2 ). The results show that chemical reactions between the atomic hydrogen of the plasma and the oxygen of the silicon occur. They decrease the oxygen content in silicon from 3 × 10 17 at./cm 3 down to 2 × 10 16 at./cm 3 , while the residual hydrogen in silicon is close to 2 × 10 15 at./cm 3 . This passivates the dangling bonds of ultrapure silicon with a high thermal stability up to 1000 K. The objective of this paper is to demonstrate that the hydrogen in the plasma modifies the electronic properties of the material to achieve a very good photocurrent even though the dislocation density of the silicon is very high.

The Mechanism of Hydrogen Plasma Passivation for Poly-Crystalline Silicon Thin Film

On the passivation mechanism of poly-silicon and thin silicon oxide on crystal silicon wafers

Floating Low-Temperature Radio-Frequency Plasma Oxidation of Polycrystalline Silicon-Germanium

Optimum Hydrogen Injection in Phosphorus-Doped Polysilicon Passivating Contacts

In situ Photoluminescence Study of Plasma Effects on Passivation of Crystalline Silicon Coated with Aluminum Oxide

Photovoltaic silicon produced by thermal plasma: Influence of atomic hydrogen on oxygen elimination and passivation of the crystal defects

Preparation and Photoluminescence of Nanocrystalline Si-Rich Silicon Oxide Films by Pecvd

Role of Hydrogen Plasma Pretreatment in Improving Passivation of the Silicon Surface for Solar Cells Applications

Non-equilibrium,Atmospheric-pressure Plasma Jet for Depositing Silicon Oxide Films

Dry Passivation Process for Silicon Heterojunction Solar Cells Using Hydrogen Plasma Treatment Followed by In Situ a-Si:H Deposition

Influence of Ultrathin Amorphous Silicon Layers on the Nucleation of Microcrystalline Silicon Films under Hydrogen Plasma Treatment

Detailed Study of SiOxNy:H/Si Interface Properties for High Quality Surface Passivation of Crystalline Silicon

High-Pressure Water-Vapor Annealing for Enhancement of A-Si:H Film Passivation of Silicon Surface

Electron-beam-induced current study of hydrogen passivation on grain boundaries in multicrystalline silicon: Influence of GB character and impurity contamination

Si Surface Passivation By Siox:H Films Deposited By A Low-Frequency Icp For Solar Cell Applications

Modulation Effect of Plasma Power on Crystalline Volume Fraction of Silicon Films in the Phase Transition from A-Si:H to /spl Mu/c-Si:H

The Power Source Effect on SiOx Coating Deposition by Plasma Enhanced Chemical Vapor Deposition

Low-Temperature Floating Plasma Oxidation of Poly-SiGe

Mechanisms of Silicon Surface Passivation by Negatively Charged Hafnium Oxide Thin Films

Investigation on the Impact of Hydrogen on the Passivation of Silicon Surface States in Clean and Copper Contaminated Conditions