Abstract:It is relatively easy to obtain highly oriented/textured Ba(ZrxTi1–x)O3 (BZT) films by magnetron sputtering, but it is complicated to control the composition of these sputtered oriented films. Here, a series of BZT ceramic targets with different ingredients (x = 0.05, 0.1, 0.15, 0.2, 0.25, and 0.3) and a BaTiO3 (x = 0) target were fabricated by solid-state sintering. Then, the corresponding BZT thin films were deposited on LaNiO3 (LNO) buffered Pt/Ti/(001)Si substrates adopting radio-frequency magnetron sputtering. Benefit from the prefabricated (001)-LNO buffer layer and optimized BZT film preparation process, all BZT films exhibit highly (00l) preferred orientation. However, the degree of orientation, lattice parameter, dielectric properties, ferroelectric behaviors, and energy-storage characteristics are all highly dependent on the Zr content of BZT films sputtered by targets with the same composition. (00l)-oriented BZT films with relatively low Zr content have a better crystalline structure [narrower full width at half maximum (FWHM), larger grains]. It is also found that the rising of the Zr content in (00l)-oriented BZT films will result in a larger out-of-plane lattice parameter, and these results indicate that the doping amount of Zr will strongly change the heterointerface stress/strain states and the growth mode of the oriented films, and then effectively tailor their electric performances.

Effect of deposition angle on the deposition rate, microstructure, electrical and optical properties of magnetron sputtered ZrB 2 thin films

Microstructure and Optical Properties of ZnO Films Deposited by Radio-frequency Reactive Magnetron Sputtering

Effect of Sputtering-Target Composition on the Structure, Dielectric, Ferroelectric, and Energy Storage Properties of Highly (00L)-Oriented Ba(ZrxTi1–x)O3 Films

Deposition and Characterization of AZO Thin Films on Flexible Glass Substrates Using DC Magnetron Sputtering Technique

The Effects of Oxygen Partial Pressure and Substrate Temperature on the Structural and Optical Properties of Zno Films

Effect of substrate-tilting angle-dependent grain growth and columnar growth in ZnO film deposited using radio frequency (RF) magnetron sputtering method

Effect of the Substrate Temperature on the Property of ZnO Films Deposited by Magnetron Sputtering with DC at the Low Power

Effect of technologic parameters on the performances of ZAO thin films deposited by magnetron sputtering

The Effect of Deposition Power on the Micro-Structure and Dielectric Response of Pb0.4sr0.6tio3 Thin Films

Deposition Condition Investigation of High c-axis Preferred Orientation ZnO Films Produced by RF Magnetron Sputtering

Effect of sputtering power on the microstructure and photelectric properties of Al doped ZnO thin films

Microstructure, infrared optical properties and thermal stability of ZrB2 and double-layer-structure Al2O3/ZrB2 thin films by magnetron sputtering technique

Effects of deposition angle on the thin film quality of indium tin oxide grown by single beam ion source-assisted magnetron sputtering

Influence of Sputtering Power on Properties of ZnO Thin Films Fabricated by RF Sputtering in Room Temperature

Effect of film thickness on surface morphology and optical properties of nanostructured Zinc Aluminum Oxide thin films deposited by DC magnetron sputtering

Microstructure and Young's Modulus of ZrN Thin Film Prepared by Dual Ion Beam Sputtering Deposition

Effects of deposition conditions on the structural and acoustic characteristics of (1120) ZnO thin films on R-sapphire substrates.

Effect of Substrate Temperature on Performance of ZAO Thin Films Deposited by Magnetron Sputtering

Effect of substrate bias on the microstructure and mechanical and tribological properties of ZrNbTiMo refractory high entropy alloy film

Resputtering effect during MgO buffer layer deposition by magnetron sputtering for superconducting coated conductors

Effect of Substrate Temperature and Deposition Power on the Surface Morphology and Optical Properties of ZnO:Mg Thin Films Deposited by DC Magnetron Sputtering