Abstract:In this study, silicon nitride (SiNx) thin films were deposited on polyimide (PI) substrates as barrier layers by a plasma enhanced chemical vapor deposition (PECVD) system. The gallium-doped zinc oxide (GZO) thin films were deposited on PI and SiNx/PI substrates at room temperature (RT), 100 and 200 °C by radio frequency (RF) magnetron sputtering. The thicknesses of the GZO and SiNx thin films were controlled at around 160 ± 12 nm and 150 ± 10 nm, respectively. The optimal deposition parameters for the SiNx thin films were a working pressure of 800 × 10-3 Torr, a deposition power of 20 W, a deposition temperature of 200 °C, and gas flowing rates of SiH₄ = 20 sccm and NH₃ = 210 sccm, respectively. For the GZO/PI and GZO-SiNx/PI structures we had found that the GZO thin films deposited at 100 and 200 °C had higher crystallinity, higher electron mobility, larger carrier concentration, smaller resistivity, and higher optical transmittance ratio. For that, the GZO thin films deposited at 100 and 200 °C on PI and SiNx/PI substrates with thickness of ~1000 nm were used to fabricate p-i-n hydrogenated amorphous silicon (α-Si) thin film solar cells. 0.5% HCl solution was used to etch the surfaces of the GZO/PI and GZO-SiNx/PI substrates. Finally, PECVD system was used to deposit α-Si thin film onto the etched surfaces of the GZO/PI and GZO-SiNx/PI substrates to fabricate α-Si thin film solar cells, and the solar cells' properties were also investigated. We had found that substrates to get the optimally solar cells' efficiency were 200 °C-deposited GZO-SiNx/PI.

Investigation of in situ grown P-doped nc-SiOx: H thin film as the n layer for the application of thin film solar cell

Investigation in Feasibility of Molybdenum As A Back Contact Layer for Silicon Based Quantum Dot Solar Cells

Using phosphorus doped hydrogenated silicon oxycarbide film as a window layer on the light entrance side of silicon heterojunction solar cells: The role of phase separation on electron transport

PROPERTIES OF PECVD SiNx FILM FOR SOLAR CELLS

Microstructure and Photoelectric Properties of P-Doped Silicon-Rich Sinx Film As an N-Type Layer for Pin-Type Amorphous Silicon Thin Film Solar Cells

Development of high conducting phosphorous doped nanocrystalline thin silicon films for silicon heterojunction solar cells application

Growth and Characterization of Boron-Doped na-Si:H Films Used as Window Layer Material of Solar Cells

Influence of Boron-doping on Electrical Properties of Na-Si:H Thin Film Prepared by PECVD

Fabrication and Research of SiO_x :H Thin Film As an Interlayer in Amorphous/microcrys-Talline Silicon Solar Cells

Electrical and Optical Properties of Boron‐doped Nanocrystalline Silicon Films Deposited by PECVD

Doped Microcrystalline Silicon Layers for Solar Cells by 13.56 Mhz Plasma-Enhanced Chemical Vapour Deposition

Doped Silicon Nanocrystals From Organic Dopant Precursor By A Sicl4-Based High Frequency Nonthermal Plasma

Structural and optical properties of phosphorous doped nanocrystalline silicon deposited using a VHF PECVD process for silicon heterojunction solar cells and optimization of a simple p-n junction cell using SCAP-1D tool

Role of SiN x Barrier Layer on the Performances of Polyimide Ga₂O₃-doped ZnO p-i-n Hydrogenated Amorphous Silicon Thin Film Solar Cells

Highly Doped P-Type Nanocrystalline Silicon Thin Films Fabricated by Low-Frequency Inductively Coupled Plasma Without H-2 Dilution

Fabrication and Optimization of Single-Junction Nc-Si:H N–i–p Solar Cells Using Si:H Phase Diagram Concepts Developed by Real Time Spectroscopic Ellipsometry

Improved Device Performance of Si-based Heterojunction Solar Cells by Using Phosphorus Doped Si Nanocrystals Embedded in SiC Host Matrix

Deposition of P-Type Nanocrystalline Silicon Using High Pressure in a VHF-PECVD Single Chamber System

Deposition of Boron-Doped Nanocrystalline Silicon Carbide Thin Films Using H2-Ar Mixed Dilution for the Application on Thin Film Solar Cells

The Influence of N-Layer on Properties of Microcrystalline Silicon Solar Cells on Flexible Substrates

Synergetic effect of gas compositions on material properties of n‐type nanocrystalline silicon oxide prepared by plasma enhanced chemical vapor deposition