Abstract:Fabrication of nano-crystalline thin film solar cell by co-sputtering of silicon and aluminum, and metal induced crystallization is reported in this paper. After a brief introduction on magnetron sputtering and aluminum induced crystallization techniques, it discusses the drawbacks of "aluminum induced layer exchange" concept as the common method for fabricating poly-Si thin films; and proposes Si-Al co-sputtering as a simple alternative fabrication method. Then a three-steps process is introduced for the fabrication of "Al electrode/n-Si wafer/p-Si thin film/Al electrode" solar cell. Material and electrical characterizations of the fabricated p-Si thin films are done by Raman spectroscopy, X-ray diffraction, optical microscopy, scanning electron microscopy and Hall Effect measurement to study the crystallization ratio, grain size, morphology, carrier density and mobility of the prepared films, respectively. The best fabricated samples show a crystallization ratio of 88% and the largest grain size of 68 nm. The hole concentration in the films is in the order of 10(18) to 10(19) cm(-1) with a maximum mobility value of 17 cm(2)/V s. Then, photovoltaic properties of the fabricated solar cells are determined by under dark and illumination J-V curves, and external quantum efficiency measurements. Dark J-V curve of the best sample represents an ideality factor of 1.39, rectification ratio of 1993 at 1 V and reverse saturation current density of 62.1 nA/cm(2) which confirms the formation of a good p-n junction. The illuminated J-V curve under AM1.5G conditions exhibits a photovoltaic conversion efficiency of 6.02% for the best sample, with a short circuit current density of 24.9 mA/cm(2) and open circuit voltage of 456 mV. The external quantum efficiency of this sample reaches to more than 59% at the wavelength of 700 nm. Finally, a simple model is proposed to describe the formation of nano-crystalline Si thin film, deposited by Si-Al co-sputtering, during the thermal annealing.

Fabrication and Research of SiO_x :H Thin Film As an Interlayer in Amorphous/microcrys-Talline Silicon Solar Cells

Single-chamber Deposition of Intrinsic Microcrystalline Silicon Thin Film and Its Application in Solar Cells

Fabrication of Microcrystalline Silicon Materials and Microcrystalline Silicon Solar Cells and Study on Their Properties

Fabrication of 1nm/s High Deposition Microcrystalline Silicon and Its Application in Solar Cells

Development of Highly Stable Hydrogenated Amorphous Silicon Films for Application in Solar Cells

STUDY ON MICROCRYSTALLINE SILICON THIN FILM SOLAR CELLS ON FLEXIBLE SUBSTRATE

Doped Microcrystalline Silicon Layers for Solar Cells by 13.56 Mhz Plasma-Enhanced Chemical Vapour Deposition

Low Temperature and High Deposition Rate Fabricating A-Si:H Thin Films and Solar Cells

Microcrystalline Silicon‐carbon Alloys As Anti‐reflection Window Layers in High Efficiency Thin Film Silicon Solar Cells

Nano-crystalline Thin Films Fabricated by Si-Al Co-Sputtering and Metal Induced Crystallization for Photovoltaic Applications

Using phosphorus doped hydrogenated silicon oxycarbide film as a window layer on the light entrance side of silicon heterojunction solar cells: The role of phase separation on electron transport

Deposition and Characterization of High-Efficiency Silicon Thin-Film Solar Cells by HF-PECVD and OES Technology

Growth and Characterization of Boron-Doped na-Si:H Films Used as Window Layer Material of Solar Cells

MoOx Hole Collection Layer for A-Si: H Based Photovoltaic Cells

Fabrication of High-Quality Boron-Doped Microcrystalline Silicon Thin Films on Several Types of Substrates

Investigation of in situ grown P-doped nc-SiOx: H thin film as the n layer for the application of thin film solar cell

Performance Enhancement of Thin-Film Silicon Solar Cells by Development of Core Component Layers

Role of SiN x Barrier Layer on the Performances of Polyimide Ga₂O₃-doped ZnO p-i-n Hydrogenated Amorphous Silicon Thin Film Solar Cells

Research on the optimum hydrogenated silicon thin films for application in solar cells

P-silicon Thin Film Fabricated by Magnetron Sputtering and Aluminium Induced Crystallization for Schottky Silicon Solar Cells

Key Issues for High-Efficiency Silicon Thin Film Solar Cells Prepared by RF-PECVD under High-Pressure-depletion Conditions