Abstract:Microcrystalline silicon, which is widely used in the microelectronics industry, is usually fabricated by chemical vapor deposition techniques. In recent years, magnetron sputtering has been considered as an alternative because it is a simpler, cheaper and more eco-friendly technique. The big drawback of this technique, however, is the need to recrystallize the as-deposited amorphous silicon, which can be done by metal-induced crystallization. Among the different suitable metals, copper has not been extensively investigated for this purpose. Furthermore, the applicability of the microcrystalline film prepared by this method has not been evaluated for photovoltaic device fabrication. Therefore, this paper reports the fabrication of p-type microcrystalline silicon thin film by magnetron sputtering and copper-induced crystallization techniques, and evaluates its appropriateness for solar cell fabrication. In the first step, 60 nm of silicon followed by 10 nm of copper were deposited on n-type silicon wafer and glass substrates, both by the magnetron sputtering technique. Then, the as-deposited samples were annealed at temperatures from 450 °C to 950 °C. The crystal properties of the resulting films were characterized by Raman and X-ray diffraction spectroscopies and optical and secondary emission microscopies, while their electrical characteristics were determined by Hall-effect, J-V curve and external quantum efficiency measurements. These characterizations confirmed the formation of a layer of microcrystalline silicon mostly in the <111> direction with a crystallization ratio of 93% and a largest grain size of 20 nm. The hole concentration and mobility of the fabricated p-type microcrystalline silicon layer were about 1017~1019 cm−3 and 8 cm2/V.s, respectively. By using the fabricated film as the emitter layer of a p-n junction solar cell, a good rectification ratio of 4100 and reverse saturation current density of 85 nA.cm−2 were measured under dark conditions. The highest photovoltaic conversion efficiency, i.e., 2.6%, with an open-circuit voltage of 440 mV and short-circuit current density of 16.7 mA/cm2, were measured under AM1.5G irradiance. These results indicate that microcrystalline silicon created by magnetron sputtering and copper-induced crystallization has considerable potential for photovoltaic device fabrication.

Fabrication of Microcrystalline Silicon Materials and Microcrystalline Silicon Solar Cells and Study on Their Properties

Single-chamber Deposition of Intrinsic Microcrystalline Silicon Thin Film and Its Application in Solar Cells

A PRELIMINARY STUDY ON MICROCRYSTALLINE SILICON MATERIALS AND SOLAR CELLS FABRICATED BY VHF-PECVD

STUDY OF RELATIONSHIP BETWEEN MICROCRYSTALLINE SILICON THIN FILM AND SOLAR CELLS

Fabrication of 1nm/s High Deposition Microcrystalline Silicon and Its Application in Solar Cells

Fabrication of Microcrystalline Silicon Films by VHF-PECVD and Their Microstructure Study

Microcrystalline SiGe Prepared by VHF-PECVD for Thin Film Solar Cells

STUDY ON MICROCRYSTALLINE SILICON THIN FILM SOLAR CELLS ON FLEXIBLE SUBSTRATE

Silicon Rich Carbide As A Conductive Substrate For Si Qd Solar Cells

Fabrication and Research of SiO_x :H Thin Film As an Interlayer in Amorphous/microcrys-Talline Silicon Solar Cells

Fabrication of High Voltage GaAs Micro-Solar Cell Arrays

Characteristics of microcrystalline silicon films grown by plasma enhanced chemical vapor deposition

Investigation of Microcrystalline Silicon Thin Film Fabricated by Magnetron Sputtering and Copper-Induced Crystallization for Photovoltaic Applications

Microcrystalline silicon carbide window layers in thin film silicon solar cells

Microcrystalline Silicon Thin Film Solar Cells with Microcrystalline Silicon Carbide Window Layers and Silicon Absorber Layers Both Prepared by Hot‐Wire CVD

Microcrystalline Silicon‐carbon Alloys As Anti‐reflection Window Layers in High Efficiency Thin Film Silicon Solar Cells

Study on Quantum Efficiencies of Microcrystalline Silicon Solar Cells on Flexible Substrates

Fabrication of Microcrystalline Silicon Thin Film and the Study of Its Microstructure and Stability

Control of crystalline volume fraction of μC-Si thin film using 40.68 MHz PECVD system for solar cell application

Structure Studies of Microcrystalline Silicon Thin Film Using Raman Scattering and Photo Thermal Deflection Spectra

Nano-crystalline Thin Films Fabricated by Si-Al Co-Sputtering and Metal Induced Crystallization for Photovoltaic Applications