Abstract:Abstract Recently, flat panel display technologies are based on amorphous silicon (a-Si), polycrystalline silicon (poly-Si) or amorphous oxide semiconductor (AOS) thin film transistors (TFTs) technology. In order to reach higher performance for ultra-high resolution display applications, the material selection for the channel layer is vital. AOS TFTs drawn lots of attention because of its advantages such as low leakage current, high driving current and high uniformity [1,3]. In this work, we presented a novel amorphous oxide semiconductor (AOS) material of gallium-free a-InWZnO thin film transistors (IWZO TFTs) which is very promising to be applied for ultra-high resolution display technology. Experiment In this work, we demonstrated the structure of a-IWZO TFTs processes. Figure 1 shows the schematic of the TFT cross-section. After growing a 550 nm thermal oxide layer as buffer layer, a 25-nm-thick of molybdenum was deposited by DC-sputter as the bottom gate electrode. A 10-nm-HfO 2 was deposited by plasma-enhanced atomic layer deposition (PEALD) system as high-κ gate dielectric (GI). Then, post deposition annealing (PDA) was carried out to enhance the quality of the insulator layer. Next, an ultra-thin body a-IWZO was deposited by RF-sputter as channel layer. Finally, source and drain were defined by lift-off process and the gate contact via was etched by dry etching to finish the device fabrication. Result and Discussion Figure 1(b) shows the negative gate bias stress (NGBS) transfer curve (I D -V G ) of a-IWZO TFTs with passivation layer. The experimental results have shown that passivation layer could keep the back channel of IWZO channel from exposing to oxygen and hydrogen from the atmosphere. Without the passivation layer, the back channel would contact moisture leading the diffused hydrogen atoms to fill oxygen vacancy sites and de-trap free carriers, causing the V TH shifts negatively. The ultra-thin a-IWZO TFTs with passivation layer exhibited a low subthreshold swing (S.S.) of 89.7 mV/dec, high on/off current ratio (I ON /I OFF ) of 2.1×10 7 and small threshold voltage shift (ΔV th ) of -0.097 V during NGBS of -2MV/cm with 2000s. To sum up, the passivation layer could enhance the a-IWZO TFTs reliability. Reference [1] Kamiya, H. Hosono, NPG Asia Mater ., vol. 2, pp. 15, 2010. [2] Nomura, H. Ohta, A. Takagi, T. Kamiya, M. Hirano, and H. Hosono, nature, vol. 432, no. 7016, pp. 488-492, 2004. [3] Y. Kuo, C. M. Chang, I. H. Liu, and P. T. Liu, Scientific reports, vol. 9, no. 1, pp. 1-7, 2019. Figure 1

High-performance amorphous gallium indium zinc oxide thin-film transistors through N2O plasma passivation

High-Performance A-Ingazno Thin-Film Transistors with Extremely Low Thermal Budget by Using a Hydrogen-Rich Al2O3 Dielectric

High-performance a-ITZO TFTs with high bias stability enabled by self-aligned passivation using a-GaOx

Thin Film Transistor Using Amorphous InGaZnO Films as Both Channel and Source/Drain Electrodes

Performance Enhancement of Channel-Engineered Al-Zn-Sn-O Thin-Film Transistors with Highly Conductive In-Ga-Zn-O Buried Layer via Vacuum Rapid Thermal Annealing

Deep Sub-Micron Self-Aligned Bottom-Gate Amorphous InGaZnO Thin-Film Transistors With Low-Resistance Source/Drain

Coplanar amorphous-indium-gallium-zinc-oxide thin film transistor with He plasma treated heavily doped layer

High-Performance Amorphous InGaZnO Thin-Film Transistor Gated by HfAlOₓ Dielectric with Ultralow Subthreshold Swing

Improvement of device characteristics of plasma-treated indium gallium zinc oxide thin-film transistors through thermal annealing

Enhanced performances of a-IGZO TFTs with oxide passivation layers fabricated by hollow cathode assisted PLD

Amorphous indium–gallium–zinc–oxide thin-film transistors using organic–inorganic hybrid films deposited by low-temperature plasma-enhanced chemical vapor deposition for all dielectric layers

Optimizing Oxygen Plasma Treatment Time to Improve the Characteristics of a-IGZO Thin-Film Transistors and Resistive-Load Inverters

Comparison of N-2 and Ar Plasma Treatment for Source/Drain Formation in Self-Aligned Top-Gate Amorphous Ingazno Thin Film Transistor

N2O plasma treatment suppressed temperature-dependent sub-threshold leakage current of amorphous indium–gallium–zinc-oxide thin film transistors

High Reliability Tungsten-Doped Indium Zinc Oxide Thin Film Transistors for Display Applications

P‐9: Parylene / Al2O3 Double Layer Passivated Amorphous InGaZnO Thin‐Film Transistors

Performance and Stability Improvements of Back-Channel-Etched Amorphous Indium–Gallium–Zinc Thin-Film-Transistors by CF 4 +O 2 Plasma Treatment

High performance amorphous IGO TFTs grown at low temperature

Influence of Oxygen Plasma Treatment on the Amorphous IGZO Thin Film Transistors

High Performance Indium‐Gallium‐Zinc Oxide Thin Film Transistor via Interface Engineering

Room-Temperature-Processed Flexible Amorphous InGaZnO Thin Film Transistor.