Abstract:Bulk lifetime studies of crystalline silicon wafers, e.g. with the aim of studying the light-induced degradation and regeneration behavior, require low-temperature surface passivation schemes that do not alter the silicon bulk properties, e.g. through hydrogenation. Aluminum oxide (Al2O3) can provide an excellent and stable surface passivation, however, in order to achieve the best possible surface passivation, an annealing step at ∼400°C is typically required, which has been found to alter the bulk properties of some silicon materials. Hence, in this contribution we examine the possibility of passivating the silicon surface using Al2O3 layers that have seen a much lower thermal budget. We demonstrate that we are able to achieve an excellent silicon surface passivation using atomic-layer-deposited Al2O3 with measured effective surface recombination velocities Seff as low as 1.3 cm/s without exceeding a temperature of 250°C. We are able to achieve such excellent low-temperature passivation by applying a post-deposition annealing step at 250°C in combination with the deposition of negative Corona charges on the Al2O3 surface. For samples annealed at only 220°C, we still reach very low Seff values of 2 cm/s after deposition of negative Corona charges. We demonstrate that the Corona-charged low-temperature Al2O3 passivation shows only a slight degradation from an Seff of 1.6 cm/s to an Seff of 5 cm/s after 218 days of storage. Even without any post-deposition anneal and only negative Corona charges deposited, we achieve stable Seff values of 15 cm/s. As an alternative to Corona charging, a short exposure to intense UV light (λ = 395 nm) also significantly improves the surface passivation quality of low-temperature-annealed Al2O3-passivated silicon samples. However, the best surface passivation for the latter method is limited to an Seff value of 6.6 cm/s, which is still quite reasonable for bulk lifetime studies.

Excellent crystalline silicon surface passivation by amorphous silicon irrespective of the technique used for chemical vapor deposition

Demonstration of Excellent Crystalline Silicon Surface Passivation (S < 1.27 cm/s) by High‐Rate DC‐Sputtered Hydrogenated Amorphous Silicon

Real-time monitoring of surface passivation of crystalline silicon during growth of amorphous and epitaxial silicon layer

High-Pressure Water-Vapor Annealing for Enhancement of A-Si:H Film Passivation of Silicon Surface

Low-temperature silicon surface passivation for bulk lifetime studies based on Corona-charged Al2O3

Amorphous/Crystalline Silicon Interface Stability: Correlation between Infrared Spectroscopy and Electronic Passivation Properties

Aluminum Oxide Deposited by Pulsed-DC Reactive Sputtering for Crystalline Silicon Surface Passivation

Influence of C_2H_4 on the Properties of Amorphous Silicon Film Grown by Chemical Vapor Deposition

Dry Passivation Process for Silicon Heterojunction Solar Cells Using Hydrogen Plasma Treatment Followed by In Situ a-Si:H Deposition

Cold Deposition of Large-Area Amorphous Hydrogenated Silicon Films by Dielectric Barrier Discharge Chemical Vapor Deposition

Novel silicon surface passivation by porous silicon combined with an ultrathin Al2O3 film

Effective Passivation of Black Silicon Surfaces via Plasma‐Enhanced Chemical Vapor Deposition Grown Conformal Hydrogenated Amorphous Silicon Layer

Significant Improvement of Passivation Performance by Two-Step Preparation of Amorphous Silicon Passivation Layers in Silicon Heterojunction Solar Cells*

Passivation of textured crystalline silicon with small pyramids by silicon nitride films formed by catalytic chemical vapor deposition and phosphorus catalytic impurity doping

Surface Recrystallization Model of Fully Amorphized C3H5-Molecular-Ion-Implanted Silicon Substrate

Comparison of crystalline-silicon/amorphous-silicon interface prepared by plasma enhanced chemical vapor deposition and catalytic chemical vapor deposition

Novel Sandwich Structure for Aluminum Induced Crystallization of Amorphous Silicon Thin Films at Low Temperature

Bulk Defects and Hydrogenation Kinetics in Crystalline Silicon Solar Cells With Fired Passivating Contacts

Dual functions of anti-reflectance and surface passivation of the atomic layer deposited Al2O3 films on crystalline silicon substrates

Improved Silicon Surface Passivation by ALD Al2O3/SiO2 Multilayers with In‐Situ Plasma Treatments

Mechanisms of Silicon Surface Passivation by Negatively Charged Hafnium Oxide Thin Films