Abstract:In this study, nanostructured non-stoichiometric TiO2-x compacts were prepared by the in-situ reduction of rutile titanium oxide (TiO2) powder with urea powder via spark plasma sintering (SPS). The crystal structure and particle size of the prepared compacts were examined. The XRD patterns revealed that TiO2 could be reduced easily by the urea powder to obtain non-stoichiometric TiO2,-x and the compacts still possessed rutile crystal structures. The average particle sizes of the compacts were less than 250 nm, successfully obtaining the nonstoichiometric TiO2-x with uniform nanostructures at the sintering temperature of 1073 K. In addition, nanostructured TiO2-x compacts with Magne & PRIME;li phase TinO2n-1 (n = 2, 4, 8) were fabricated by varying the volume fraction of Ti powder in a urea environment via SPS. The results suggested that addition of Ti powder contributed to the formation of Magne & PRIME;li phases TinO2n-1, and the value of n decreased with an increase in the volume fraction of the Ti powder. Furthermore, the thermoelectric properties of the compacts sintered with and without Ti powder were both investigated. The TiO2-U13.3-Ti10 compact displayed the highest power factor of 5.04 & mu;Wcm- 1K-2 at 973 K. A lower thermal conductivity was achieved by TiO2-U13.3-Ti10 compact in the temperature range of 373-973 K, approximately 3 Wm- 1K-1, due to the nanostructures and Magne & PRIME;li phases. The highest ZT value of 0.146 was obtained for the TiO2-U13.3-Ti10 compact at 973 K, achieving a reasonable enhancement of thermoelectric properties.

Fabrication and Thermoelectric Properties of Magneli Phases by Adding Ti into TiO<sub>2</sub>

Fabrication And Thermoelectric Properties Of Magneli Phases By Adding Ti Into Tio2

Magnèli Phase Ti O2-1 Bulks Prepared by SPS Followed by Carbon Reduction and Their Thermoelectric Performance

Thermoelectric Performance Enhancement of Magnéli Phase Ti n O 2 n −1 Compacts by In Situ Reduction of TiO 2 with Charcoal Powder via Spark Plasma Sintering

Fabrication of Nanostructured Non-Stoichiometric TiO2-x by Spark Plasma Sintering for Enhancing Its Thermoelectric Properties

Fabrication and Performance Enhancement of TiO2-x Thermoelectric Material by In-Situ Reduction

Fabrication of high-performance Magnéli phase Ti4O7 ceramics by in-situ hot-pressed sintering in a single step

The Effect of Magnéli phase Ti4O7 as an additive in air-sintered TiO2 ceramics

Fabrication of non-stoichiometric titanium dioxide and its thermoelectric properties

Fabrication of Ti1-Xcrxoz and Analysis of Its Microstructure and Thermoelectric Properties

Fabrication and Thermoelectric Properties of Fine-Grained TiNiSn Compounds

Conduction and sintering mechanism of high electrical conductivity Magnéli phase Ti4O7

Magnetically Enhanced Thermoelectric Performance of Ti0.75NiSb+x Mol % Fe (x = 0-5) Nanocomposites.

Nonstoichiometric TiO2-x Obtained Via Spark Plasma Sintering: Thermoelectric Properties and First-Principles Calculations

A high strength and conductivity bulk Magnéli phase Ti 4 O 7 with superior electrochemical performance

Magnetically Enhanced Thermoelectric Performance of Ti 0.75 NiSb+ x mol % Fe ( x = 0-5) Nanocomposites

FABRICATION OF Ni1-xMxO (M = Li, Na) AND ITS THERMOELECTRIC PROPERTIES

Fabrication of TiNiSn-Based Half-Heusler Thermoelectric Compound by Mechanical Alloying and Spark Plasma Sintering

Fabrication of non-stoichiometric titanium dioxide by spark plasma sintering and its thermoelectric properties

The Effects of Titanium on the Phase Structure and Charge/Discharge Performance of Ml(Nicomnti)(5) Alloy

Fabrication of Thermoelectric Cualo2 and Performance Enhancement by High Density