Abstract:The control of nanostructures is crucial for enhancing the thermoelectric properties of materials. In this work, the grain growth and phase transformation of different nano-sized titanium dioxide (TiO2) powders were investigated during heat treatment and spark plasma sintering. First, the thermal behaviors of TiO2 powders with different particle sizes during heat treatment, such as grain growth, phase transformation, and adsorption properties, were studied. The results showed that the phase transformation of 7 nm anatase TiO2 occurred more easily, and the rutile phase content increased with increasing heat treatment temperature. The grain growth of 7 nm anatase TiO2 occurred at low temperature (i.e., 873 K), even the grain size increased by 13-fold at 1123 K (i.e., the phase transformation temperature). Thermogravimetry results suggested that the 7 nm anatase TiO2 powder had a greater adsorption characteristic owing to its large specific surface area. Moreover, TiO2 compacts with and without graphite were fabricated using spark plasma sintering. The results indicated that a lower sintering temperature was beneficial for maintaining the nanostructure, whereas the addition of graphite powder promoted grain growth. Furthermore, the thermal conductivity was reduced owing to the nanostructure, and the phonon thermal conductivity accounted for a dominant proportion of the total thermal conductivity. Consequently, the lowest thermal conductivity was 1.1 Wm−1K−1 at 973 K for the nanostructured compact sintered at 1073 K, which is approximately 50% lower than that of the microstructured compact sintered at 1273 K.

Fabrication of non-stoichiometric titanium dioxide and its thermoelectric properties

Fabrication of non-stoichiometric titanium dioxide by spark plasma sintering and its thermoelectric properties

Fabrication of Nanostructured Non-Stoichiometric TiO2-x by Spark Plasma Sintering for Enhancing Its Thermoelectric Properties

Nonstoichiometric TiO2-x Obtained Via Spark Plasma Sintering: Thermoelectric Properties and First-Principles Calculations

Improvement In Thermoelectric Properties Of Non-Stoichiometric Titanium Dioxide By Reduction Treatment

Fabrication and Performance Enhancement of TiO2-x Thermoelectric Material by In-Situ Reduction

Thermoelectric Properties of Non-Stoichiometric Titanium Dioxide Tio2-X Fabricated by Reduction Treatment Using Carbon Powder

Fabrication of Ti1-Xcrxoz and Analysis of Its Microstructure and Thermoelectric Properties

Study on the Fabricated Non-Stoichiometric Titanium Dioxide by In-Situ Reduction with Carbon Powder Via Spark Plasma Sintering

Fabrication And Thermoelectric Properties Of Magneli Phases By Adding Ti Into Tio2

Thermoelectric Performance Enhancement of Magnéli Phase Ti n O 2 n −1 Compacts by In Situ Reduction of TiO 2 with Charcoal Powder via Spark Plasma Sintering

Magnèli Phase Ti O2-1 Bulks Prepared by SPS Followed by Carbon Reduction and Their Thermoelectric Performance

Grain Growth and Phase Transformation of Nano-Sized Titanium Dioxide Powder During Heat Treatment and Spark Plasma Sintering

Fabrication and Thermoelectric Properties of Magneli Phases by Adding Ti into TiO<sub>2</sub>

Synthesis and characterization of Al doped non-stoichiometric ratio titanium oxide at high temperature and pressure

Record High Thermoelectric Performance in Bulk SrTiO3 Via Nano-Scale Modulation Doping

Effect of Cu powder addition on thermoelectric properties of Cu/TiO 2-x composites

Fabrication of Thermoelectric Cualo2 and Performance Enhancement by High Density

Graphite sintered strontium praseodymium titanate perovskite for thermoelectric applications

Realization of an Ultrahigh Power Factor and Enhanced Thermoelectric Performance in TiS2 Via Microstructural Texture Engineering.

Fabrication and Thermoelectric Properties of Fine-Grained TiNiSn Compounds