Abstract:The control of nanostructures is crucial for enhancing the thermoelectric properties of materials. In this work, the grain growth and phase transformation of different nano-sized titanium dioxide (TiO2) powders were investigated during heat treatment and spark plasma sintering. First, the thermal behaviors of TiO2 powders with different particle sizes during heat treatment, such as grain growth, phase transformation, and adsorption properties, were studied. The results showed that the phase transformation of 7 nm anatase TiO2 occurred more easily, and the rutile phase content increased with increasing heat treatment temperature. The grain growth of 7 nm anatase TiO2 occurred at low temperature (i.e., 873 K), even the grain size increased by 13-fold at 1123 K (i.e., the phase transformation temperature). Thermogravimetry results suggested that the 7 nm anatase TiO2 powder had a greater adsorption characteristic owing to its large specific surface area. Moreover, TiO2 compacts with and without graphite were fabricated using spark plasma sintering. The results indicated that a lower sintering temperature was beneficial for maintaining the nanostructure, whereas the addition of graphite powder promoted grain growth. Furthermore, the thermal conductivity was reduced owing to the nanostructure, and the phonon thermal conductivity accounted for a dominant proportion of the total thermal conductivity. Consequently, the lowest thermal conductivity was 1.1 Wm−1K−1 at 973 K for the nanostructured compact sintered at 1073 K, which is approximately 50% lower than that of the microstructured compact sintered at 1273 K.

Magnèli Phase Ti O2-1 Bulks Prepared by SPS Followed by Carbon Reduction and Their Thermoelectric Performance

Thermoelectric Performance Enhancement of Magnéli Phase Ti n O 2 n −1 Compacts by In Situ Reduction of TiO 2 with Charcoal Powder via Spark Plasma Sintering

Fabrication And Thermoelectric Properties Of Magneli Phases By Adding Ti Into Tio2

Fabrication and Thermoelectric Properties of Magneli Phases by Adding Ti into TiO<sub>2</sub>

Fabrication and Performance Enhancement of TiO2-x Thermoelectric Material by In-Situ Reduction

Fabrication of Nanostructured Non-Stoichiometric TiO2-x by Spark Plasma Sintering for Enhancing Its Thermoelectric Properties

Enhanced thermoelectric performance of n -type PbTe bulk materials fabricated by semisolid powder processing

Fabrication of non-stoichiometric titanium dioxide and its thermoelectric properties

Fabrication of high-performance Magnéli phase Ti4O7 ceramics by in-situ hot-pressed sintering in a single step

Conduction and sintering mechanism of high electrical conductivity Magnéli phase Ti4O7

A high strength and conductivity bulk Magnéli phase Ti 4 O 7 with superior electrochemical performance

Nonstoichiometric TiO2-x Obtained Via Spark Plasma Sintering: Thermoelectric Properties and First-Principles Calculations

Fabrication and Thermoelectric Properties of Fine-Grained TiNiSn Compounds

Fabrication of Ti1-Xcrxoz and Analysis of Its Microstructure and Thermoelectric Properties

Improvement In Thermoelectric Properties Of Non-Stoichiometric Titanium Dioxide By Reduction Treatment

Fabrication of TiNiSn-Based Half-Heusler Thermoelectric Compound by Mechanical Alloying and Spark Plasma Sintering

Fabrication of non-stoichiometric titanium dioxide by spark plasma sintering and its thermoelectric properties

Fabrication of Thermoelectric Cualo2 and Performance Enhancement by High Density

Record High Thermoelectric Performance in Bulk SrTiO3 Via Nano-Scale Modulation Doping

FABRICATION OF Ni1-xMxO (M = Li, Na) AND ITS THERMOELECTRIC PROPERTIES

Grain Growth and Phase Transformation of Nano-Sized Titanium Dioxide Powder During Heat Treatment and Spark Plasma Sintering