Abstract:High-resolution active-matrix organic light-emitting diode (AMOLED) thin-film transistor (TFT) backplane with lower power consumption is needed for augmented reality (AR) applications. The near-to-eye format of AR terminals needs facing several technical challenges, such as higher optical efficiency, wider field of view, lighter weight, and smaller size to accelerate widespread applications. For these reasons, downscaling of TFTs with amorphous-indium-gallium-zinc-oxide (a-IGZO) or LTPS is required. The channel length should be less than 1 μm and the flexible substrate is better than glass because of light weight and very thin structure. TFT technologies on polyimide (PI) substrate can support the applications for foldable and rollable displays. For flexible AMOLED, PI layer of 10 to 20 um is widely used for foldable displays. The PI layer is coated by slot coating on the top of a carrier glass with a buffer layer of carbon nanotubes (CNTs) and graphene oxide (GO) mixture coated by spray. This layer can reduce the adhesion force between PI and glass and thus mechanical detachment can be possible. The CNTs are conducting so that it can release the electrostatic discharge (ESD) damage because CNTs/GO layer exists on the bottom side of the PI substrate. The PI substrate is covered by SiO 2 and ZrAlO x layers (five layers in total starting with SiO 2 ) by plasma enhanced chemical vapor deposition and spray pyrolysis, respectively, which acts as a gas barrier. The amorphous ZrAlO x film by spray coating can be used as a high-k gate insulator and also a gas barrier. The threshold voltage of a-IGZO TFTs tends to shift toward negative gate voltage with decreasing the channel length. In this work, a ZrAlO x passivation layer is introduced for the short channel, coplanar a-IGZO TFT. A very thin ZrAlO x layer is deposited by spray pyrolysis on the top of a-IGZO TFT at the substrate temperature of 350 °C before interlayer deposition. The a-IGZO TFT with a very thin ZrAlO x layer exhibits the stable threshold voltage dependence with decreasing the channel length. The 0.8 μm channel length a-IGZO TFT with ZrAlO x layer by spray pyrolysis at the substrate temperature of 350 °C exhibits the field-effect mobility of 7.09 cm 2 V -1 s -1 , the threshold voltage of -0.6 V, and on/off current ratio of 3.3 × 10 7 . The formation of Zr-O bonds on the a-IGZO surface region reduces the carrier concentration in the a-IGZO TFT offset region, between source/drain contact and the channel, and blocks the carrier diffusion into the channel. This is the first reported self-aligned coplanar a-IGZO TFT under 1 μm channel length on a flexible substrate. Figure 1

3 Μm A‐si TFT Technology for High‐Performance and Cost‐Effective Liquid Crystal Displays

A Low Temperature Polycrystalline Si TFT Technology for Large area AMLCD Drivers

P‐21: Student Poster: Indium‐Gallium‐Zinc Oxide Thin‐Film Transistors for High‐Resolution Active‐Matrix Ferroelectric Liquid‐Crystal Displays

35.4: A 2.1‐inch AMOLED Display Based on Metal‐Induced Laterally Crystallized Polycrystalline Silicon Technology

High Performance Transparent In-Plane Silicon Nanowire Fin-Tfts Via A Robust Nano-Droplet-Scanning Crystallization Dynamics

A Hybrid A-Si and Poly-Si TFTs Technology for AMOLED Pixel Circuits

Submicron super TFTs for 3-D VLSI applications

Liquid crystal cell design of VGA field sequential color LCoS display

P‐5.27: Outdoor 55‐inch 4k‐resolution and High‐Brightness Liquid Crystal Display

Low Temperature Poly-Si TFT Technology

A Novel Ultra-Thin Channel Poly-Si TFT Technology

Fabrication Techniques of A-Si∶h TFT on Plastic Substrate

A Short-Channel TFT of Amorphous In–Ga–Zn–O Semiconductor Pixel Structure With Advanced Five-Mask Process

Sub-Micron Oxide TFT for the Era of Oxide-Based Display

Indium Zinc Oxide Nanosheet Transistor with 2 nm Channel Thickness for Monolithic Three-dimensional Integrated Circuit

Enhancing Pixel Charging Efficiency by Optimizing Thin-Film Transistor Dimensions in Gate Driver Circuits for Active-Matrix Liquid Crystal Displays

P‐40: TFT‐LCD a‐Si Wet Etch Technology

43.3: Metal‐Oxide Thin‐Film Transistors for Driving High‐Resolution Active‐Matrix Ferroelectric Liquid‐Crystal Displays

High Performance Si Nanowire TFTs with Ultrahigh On/off Current Ratio and Steep Subthreshold Swing

(Invited) Short Channel Coplanar Amorphous-Indium-Gallium-Zinc-Oxide Thin-Film Transistors on Polyimide Substrate for High Resolution Displays

High-performance thin-film transistors based on aligned carbon nanotubes for mini- and micro-LED displays